Tender For Construction Of Pd Shop At Mariyamman Kovil Street In Karumathampatti Municipality.; 1 Earthwork Open Excavation In All Soils And Sub Soils And To Full Depth As May Be Directed Except In Rock Requiring Blasting But Inclusive Of Shoring, Strutting And Baling Out Water Wherever Necessary And Depositing The Excavated Earth Within The Compound In Places Shown By Departmental Officers With An Initial Lead Of 10M And Lift Of 2M And Clearing And Leveling Etc. Complete Complying With Standard Specification. 2 Plain Cement Concrete 1:4:8 ( One Cement Four Fine Aggregates And Eight Coarse Aggregates ) Using 40Mm Size Iss Hbg Metal Including Cost And Conveyance Of All Materials To Site And Including For The Mixing, Laying And Labour Charges And All Incidential Charges Such As Water Providing Etc., Complete As Per Standard Specification 3 Supplying And Fabrication Placing In Position Of M.S. ( Or ) Rts Rods For Required Size And Length As Directed By The Deparmental Officers Approved Design Including Bending Cutting Tying And Cost Of Binding Wire Cost And Conveyance Of All Materials To Site Etc., Complete As Per Standard Specification 4 Supplying And Erecting Steel Centering Including Necessary Supports For Plane Surfaces In Foundation And Basement For Reinforced Cement Concrete Works Such As Column Footings, Plinth Beam, Grade Beam, Stair Case Steps, Bed Blocks Etc. Which Require Only Normal Strutting Using M.S. Sheets Of Size 90Cm X60cm Bg 10 Gauge Of Stiffened With Mild Steel Angles Of Size 25Mm X 25Mm X 3Mm For Boarding Laid Over Silver Oak Joists Of Size 10 X 6.50Cm Spaced At About 90 Cm Centre To Centre And Supported By The Casurina Props Of 10Cm To 13Cm Dia Spaced At 75Cm Centreto Centre Atsuitableintervals Etc. Complyingwithstandardspecification 5 Reinforced Cement Concrete 1:1 1 / 2:3 Mix Using 20 Mm Iss Metal ( One Cement One And Half Sand And Three Aggregate ) From The Approved Quarry Including Mixing, Laying, Consolidating Curing Cost And Conveyance Of All Materials To Site And All Labour Charges Etc., Complete As Per Standard Specification 6 Supplying And Erecting, Centering For Sides And Soffits Including Supports And Strutting Upto 3.29M Height For Plane Surfaces As Detailed Below In All Floors With All Cross Bracings Using Mild Steel Sheet Of 90Cm X60cm Bg 10 Gauge Stiffened With Welded M.S. Angle Of 25 X 25 X 3Mm For Boarding Laid Over Silver Oak Joists Of Size 10Cm X 6.50 Cm Spaced At About 90 Cm Centre To Centre And Supported By Casurina Props Of 10 Cm To 13 Cm Dia Spaced At Not Less Than 75 Cm Centre To Centre Or At Suitable Intervals Etc. Complete In All Floors Complying With Standard Specification. ( The Payment For Centeringshall Be Made Only After The Concrete Is Laid. The Retrieved Materials Should Be Taken Back By The Contractor ) Plane Surface Such As Rcc Square Or Rectangular Columns, Top And Bottom Slab Of Sunshade, Boxing Sill Slabs Etc., 7 Randum Rubble Masonry In Cement Mortar 1:5 Mix ( One Cement And Five Sand ) Using Best Quality Of New Rough And Bond Stones Including Simultaneiously Pointing Curing, Cost And Conveyance Of All Materials To Site And Labour Charges Etc., Complete 8 Brick Work In Cement Mortar 1:5 Mix Using ( One Cement And Five Sand ) Using Best Quality Of Country Second Class Ground Moulded Chamber Burnt Bricks Of Size ( 9X4 3 / 8X2 3 / 4 ) For Foundation Including Curing Cost And Conveyance Of All Materials To Site And All Labour Charges Etc., Complete 9 Up To Basement 10 Above Basement 11 Brick Partition Walls Using Ii Class Ground Moulded Chamber Bricks Of Size 9X43 / 8X 23 / 4In C.M 1:3Using Hoop Iron Reinforcement, If Found Necessary Standard Specification Including Finishing, Curing, Etc., Complete Complying With Standard Specification - 10 Sqm 12 Plastering With Cement Mortar 1:3, 10 Mm , Thick In All Floors Including Cost And Conveyance Of All Materilas To Site And Labour Charges Etc, Complete As Per Standard Specifications ( S.I.306 ) 13 Plastering With Cement Mortar 1:3 Mix ( One Cement And Three Sand ) To 20 Mm Thick Including Curing Cost And Conveyance Of All Materials To Site And All Labour Charges Etc., Complete 14 Supplying And Erecting, Centering For Sides And Soffits Including Supports And Strutting Upto 3.29M Height For Plane Surfaces As Detailed Below In All Floors With All Cross Bracings Using Mild Steel Sheet Of 90Cm X60cm Bg 10 Gauge Stiffened With Welded M.S. Angle Of 25 X 25 X 3Mm For Boarding Laid Over Silver Oak Joists Of Size 10Cm X 6.50 Cm Spaced At About 90 Cm Centre To Centre And Supported By Casurina Props Of 10 Cm To 13 Cm Dia Spaced At Not Less Than 75 Cm Centre To Centre Or At Suitable Intervals Etc. Complete In All Floors Complying With Standard Specification. ( The Payment For Centeringshall Be Made Only After The Concrete Is Laid. The Retrieved Materials Should Be Taken Back By The Contractor ) Plane Surfaces Such As Rcc Floor Slab, Roof Slab, Rectangular Square Tee Or Ell Beam, Lintels, Bed Blocks Staircase Waist Slab, Landing Slab, Landing Beams, Portico Beams, Portico Slab, Etc. 15 Supplying And Fixing In Position Indian Water Closet Of Size 580 X 440Mm, White Glazed Earthen Ware Of Approved Quality With P Trap Or S Trap Confirming To Is:2556 -Part Xii With Sand Cushion And Forming Flooring Alround The Closet Using 40Mm Broken Brick Jelly In Lime Concrete1:2:5 ( One Part Of Lime, Two Parts Of Sand And Five Parts Of Brick Jelly ) 100Mm Thick And Finishing The Top To Required Slope And Including Giving Necessary Connection To Cast Iron Soil Pipes / Pvc Pipes By Dismandling Brick Masonry, Reinforced Cement Concrete Roof / Floor Slab And Making Good The Disturbed Portion To Original Condition Without Leakage Etc., Complete Complying With Standard Specifications And As Directed By The Departmental Officers. 16 Supplying And Erecting Pull And Push Type Rolling Shutter With I.S.I. Make Of Approved Size And Section Using 18 Gauge G.I.Sheet With Manually Operated Type. The Shutter Shall Be Painted With One Coat Of Red Oxide Primer And The Rate Is Inclusive Of Hood Covers, Transportation Charges Etc, Complete As Per Standard Specification. 17 Supplying And Fixing Of M.S. Sheet Window Using 18 Gauge M.S. Sheet With M.S. Angle Of Size 40 X 40 X 6 Mm And M.S. Flat 25 Mm X 6 Mm And M.S. Square Bars Including Cutting, Welding, Fixing In Position Cost And Conveyance Of All Materials To Site And All Labour Charges Etc., Complete As Per Standard Specification 18 Supply And Fixing Of M.S. Iron Grill Gate Of Required Size And Design Approved By The Departmental Officers Including Cost Of Materials And Labour Charges Including One Coat Of Primer Of Red Oxide Etc., Complete As Per Standard Specification 19 Supplying And Fixing 30Mm Thick Solid Core Pvc Door Shutter With Pvc Frame ( Confirming To Is 4020 With Updated Amendments ) Consisting Of Frame Made Out Of Ms Tubes 19 Gauge Thickness And Size Of 19 X 19Mm For Styles And 15X15mm For Top And Bottom Rails. M.S. Frame Shall Be Covered With 5Mm Thick Heat Moulded Pvc ‘C Channel Of Size 30 X 50Mm Forming Styles, And 5Mm Thick 75Mm Wide Pvc Sheets For Top Rail, Lock Rail And Bottom Rail On Either Side And 10Mm ( 5Mm X 2 ) Thick 20Mm Wide Cross Pvc Sheet As Gap Insert For Top Rail, Bottom Rail.Paneling Of 5Mm Thick Pvc Sheet Bearing On Either Side And Join Together Other Side Etc. An Additional 5Mm Thick Pvc Strip Of 20Mm Width Is To Be Stack And The Interior Side Of The ‘C Channel Using Pvc Sealant Adhesive Complete, As Per Direction Of Engineer In Charge And Drawing. 20 Plastering With Cement Mortar 1:3 Mix ( One Cement And Three Sand ) To 10 Mm Thick Including Curing Cost And Conveyance Of All Materials To Site And All Labour Charges Etc., Complete As Per Standard Specification 21 Plastering With Cement Mortar 1:5 Mix ( One Cement And Five Sand ) To 12 Mm Thick Including Curing Cost And Conveyance Of All Materials To Site And All Labour Charges Etc., Complete As Per Standard Specification 22 Supply And Delivery And Fixing Of Hdpe Tank As Per Is 12701 / 1996 Including Loading, Unloading, Transportation And Labour Charges For Fixing Of The Gi Pipes And Specials For Pipe Connection Works Including Cutting, Threading And Fixing Charges Etc., 23 Dadooing Walls With Glazed Tiles ( Colour ) Of Size 305 X 200 X 6 Mm Laid In Cement Mortar 1:2 Mix To 10 Mm Thick And Painting With White Cement Using 0.40 Kg / 1 M 2 Including Finishing The Jointing And Painting With Tiles Surface Including And Labour Charges Cost And Conveyance Of All Materials To Site Etc., Complete As Per Standard Specification 24 Paving The Floor With Plain / Design Antiskirt Ceramic Tiles ( Colour And Shade As Directed ) Of Size 305 Mm X 305Mm X 6 Mm In All Floors Over A Base Layer Of Cement Mortar 1:3 ( One Cement And Three Sand ) 20Mm Thick Laid In-Situ And Pointed With Same Coloured Cement 25 Wiring With 2 X 1.5Sqmm ( 22 / 0.3 ) Pvc Insulated Single Core Unsheathed Copper Conductor Cable Of 1100V Grade In Suitable Pvc Rigid Pipe On Wall And Ceiling With Pvc Accessories In Flush With Wall With 3Mm Thick Hylum Sheet Cover With Tw Switch Box And 5A F.T.Switch With Continuos Earth Wire Connection Of 14 Swg Tc Wire And Making Good Of The Concealed Portion With Suitable Colour For Pvc Concealed Light Point ( Sd 24 ) 26 Wiring With 2 X 1.5Sqmm ( 22 / 0.3 ) Pvc Insulated Single Core Unsheathed Copper Conductor Cable Of 1100V Grade In Suitable Pvc Rigid Pipe Concealed In Wall And Ceiling With Pvc Accessories In Flush With Wall With Suitable Flush Type Tw Switch Box To House The Control Switch And Regulator, Coveredwith 3Mm Thick Hylum Sheet With Continuous Earth Wire Connection Of 14 Swg Tc Wire And Making Good Of The Concealed Portion With Suitable Colour For Concealed Fan Point ( Sd 23 ) 27 Wiring With 2 X 1.50 Sqmm ( 22 / 0.3 ) Pvc Insulated Single Core Unsheathed Copper Conductor Cable Of 1100V Grade In Suitable Pvc Rigid Pipe Concealed In Wall And Ceiling With Pvc Accessories In Flush With Wall With 150Mm X 100Mm X 113Mm Tw Switch Box With 3Mm Thick Hylum Sheet Cover For 5A 3 Pin Non Inter Locking Cs Plug With Continuous Earth Wire Connection Of 14 Swg Tc Wire And Making Good Of The Concealed Portion With Suitable Colour For Concealed Pvc Plug Point ( Sd 12 ) 28 Supply And Fixing Of Single Box Type 440 W Flu Fitting Complete With Copper Choke And Condensor With Tw Round Blocks On Wall Or Ceiling With Flu Tupe With Pvc Unsheathed Copper Leads From Terminals To The Fitting ( Sd 88 ) 29 Supply And Fixing Of 1200 Mm ( 48 ) Sweep Ac Ceiling Fan Complete With Stepped Electronics 300W Regulator, With 300 Mm Down Rod On The Existing Clamp. ( Sd 107 ) 30 Supply And Fixing Of 230 / 400 V, Mcb Short Cicuit 24 / 46 Ka, Type Of Fuse Link-Rew / 4Rc, Number Of Poles -Spn / Pp / Tp 4 Nincluding Labour Charges Cost And Conveyance Of All Materials To Site Etc., Complete As Per Standard Specification 31 Supply And Fixing Of Tneb Meter Board Suitable For 32 A Singlephase Service Connection With 3 Nosx32 Amps Fuse Unit ( 500 V ) 32A Neutral Link And Earth ( 1 X 1 / 8 Copper Flat ) On Teak Wod Plank Of Size 375 Mm X300x 19Mm With Supporting Teak Wood Reeperetc Complete ( Sd 125 ) 32 Supply And Run Of 2 Of 4 Sqmm ( 56 / 0.3 ) Pvc Insulated Single Core Unsheathed Cu.Conductor Of 1100 V Grade On 7 / 20 Gi Bearer Wire For Service Connection Mains ( Sd 56 ) 33 Supply And Run Of 2 Of 4 Sqmm ( 56 / 0.3 ) Pvc Insulated Single Core Unsheathed Cu.Conductor Of 1100 V Grade In 25 Mm Gi Pipe ( Class B ) Bend At Both Ents With Necessary Angle Iron Up Right And Supports ( Sd 70 ) 34 Supply And Fixing Of Rain Water Production Box Size Of 0.50X0.34X0.18 M Including All Cost Of Labour Charges Including Labour Charges Cost And Conveyance Of All Materials To Site Etc., Complete As Per Standard Specification 35 Painting Two Coats White Janathacem Including All Labour Charges Cost And Conveyance Of All Materials To Site Etc., Complete As Per Standard Specification 36 Painting Two Coats With Ready Mixed Plastic Emulstion Paint Of First Class Quality Paint And Approved Colour Including Priming Coat Through Scrapping Clean Removal Of Dust Etc., Complete 37 Painting Two Coats With Best Approved Quality Of Enamel Paint Over One Coat Of Priming For New Iron Work Including All Labour Charges Etc., Complete As Per Standard Specification 38 Painting And Letter Writing Two Coats With Best Approved Quality Of Enamel Paint Over One Coat Of Priming Including All Materials, Labour Charges And Cost Of Conveyance Chargesetc., Complete As Per Standard Specification 39 Supplyingof 25 Mm Dia G.I Pipes With Isi Marked Including Transporting The Same To The Site Directed By The Departmental Officers Etc Complete As Standard Specifications 40 Supply And Fixing Of 25Mm Upvc Column Pipes Which Includes All Labour Charges Etc, .Complete 41 Supplyingof 63 Mm Dia Pvc 6 Ksc Pipe With Isi Marked Including Transporting The Same To The Site Directed By The Departmental Officers Etc Complete As Standard Specifications 42 Lowering Of Pvc Rigid Pipes And Specials To Trench And Laying To Proper Grade And Alignment Jointing With Pvc Couplers With Cement Paste And Testing To The Required Pressure Including Conveyance Of Water For Filling During Testing.Etc Complete 43 Gst 18%
