tender for special repair of village lohra to pathra pav mp border in km-1 and 2 including 5 years maintenance, 1 providing, laying, spreading and compacting stone aggregates of specific sizes to water bound macadem specification including spreading in uniform thickness, hand packing, rolling with smooth wheel roller 80-100kn in stages to proper grade and camber, applying and brooming stone screening to fill up the interstices of coarse aggregate, watering and compacting to the required density grading-3 as per technical specification clause-405 2 providing and applying tack coat with bitumen vg-10 using bitument distributor at the rate of 0.30kg per sqm on the prepared bituminious surface cleaned with hydraulic broom as per technical specification clause 503 3 providing, laying and rolling of open graded premix carpet of 20mm thickness composed of 13.2mm to 5.6mm aggregates either using penetration grade bitumen vg-10 to required line, grade and level to serve as wearing course on a previously prepared base, including mixing in a hmp 30/40 tph, laying with paver finisher and rolling with a three wheel 80-100kn static roller capacity, finished to required level and grades to be followed by seal coat of either type a or type b or type c as per technical specification clause 508. (with hmp plant) 4 providing and laying seal coat sealing the voids in a bituminous surface laid to the specified levels, grade and cross fall using type c as per technical specification clause 510 5 construction of subgrade and earthen shoulders with approved material obtained from borrow pits with all lifts and leads, transporting to site, spreading, grading to required slope and compacted to meet requirement of table 300.2 6 construction of subgrade and earthen shoulders with approved material obtained from borrow pits with all lifts and leads, transporting to site, spreading, grading to required slope and compacted to meet requirement of table 300.2. 1km carted earth up to site. 7 construciton of un-reinforced, plain joint at expansion and construction joint only, plain cement concrete pavement, thickness as per design, over a prepared sub base with 43 grade cement or any other type as per clause 1501.2.3 m30 (grade), coarse and fine aggregates conforming to is:383, maximum size of coarse aggregate not exceeding 25mm mixed in a concrete mixerof not less than 0.20cum capacity and appropriate weigh batcher using approved mix design, laid in approved fixed side formwork (steel channel, laying and fixing of 125 micron thick polythene film, wedges, steel plates including levelling the form work as per drawing. spreading the concrete with shovels, rakes, compacting using needle, screed and plate vibrators and finished in continous operation including provision of contraction and expansion, construction joints, applying joint filler board near approcehes to bridges/culvert and construction joints, admixture as approved, curing of concrete slabs for 14 days, using curing compound (where speficied) and water finishing to lines and grade as per drawing and technical specifications clause 15-01 8 maintenance of bituminous surface road and gravel of wbm road including filling pot hols and patch repair etc. restroration of rain cuts and dressing of side slop / berms making up of berms / shoulders maintenance of drain, maintenance of culvert, maintenance of guard rails and parapet, maintenance of road sign, speed breakers standing tree at adjacent of road wherever required maintenance of 200m stone (hectometre) and kilometer stones, cutting of branches of trees, shrub and trimming of glass and weeds etc while washing of parapet including cd work, paiting of guard stones, refixing of displaced gaurd stone (as per performance index annexure-1) mentioned in go no-17/2024/ sa-113/23-1-2024-23-1099/113 /2023 dated 16-01-2024 & e-in-c letter no-3689/c-oprmc / mul-2023-24 dated 17-02-2024 subjected to approval from govt. maintenance of 1st year after completion of work @ 0% of total cost of pc work 9 maintenance cost for 2nd year @ 1.50% cost of pc work 10 maintenance cost for 3rd year @ 3.00% cost of pc work 11 maintenance cost for 4th year @ 4.50% cost of pc work 12 maintenance cost for 5th year @ 6.00% cost of pc work 13 maintenance of concrete surface including crack sealing spot patching including restroration of rain cuts and dressing of side slop / berms making up of berms / shoulders maintenance of drain, maintenance of culvert, maintenance of guard rails and parapet, maintenance of road sign, speed breakers standing tree at adjacent of road wherever required maintenance of 200m stone (hectometre) and kilometer stones, cutting of branches of trees, shrub and trimming of glass and weeds etc while washing of parapet including cd work, paiting of guard stones, refixing of displaced gaurd stone (as per performance index annexure-1) mentioned in go no-17/2024/ sa-113/23-1-2024-23-1099/113 /2023 dated 16-01-2024 & e-in-c letter no-3689/c-oprmc / mul-2023-24 dated 17-02-2024 subjected to approval from govt. maintenance of 1st year after completion of work @ 0% of total cost of cc work 14 maintenance cost for 2nd year @ 0.25 % cost of cc work 15 maintenance cost for 3rd year @ 0.50 % cost of cc work 16 maintenance cost for 4th year @ 0.75 % cost of cc work 17 maintenance cost for 5th year @ 1.00 % cost of cc work