|
| 1 | Fabricating, supplying and erection of...ms long hot dip Galvanized Octagonal hot dip Pole with BSEN10025 grade S355JO steel plate for shaft,IS2062 for base plate with door opening arrangements, including suitable boards, Bake lite sheet and MCBs as per IS specification suitable to with stand the wind speed of 47m/s for.......m Pole in single section and single joint welded as per IS9595/IS10178AWS having dimensions bottom.....mm, top....mm with 3mm thick, suitable base plate and 4Nos of.....long J bolts along with template and the Pole shall be hot dip galvanized in single dipping with not less than 65micron as per ASTM-A123 and 153 etc as per drawing appended. |
| 2 | 12 m - Top 90 mm and Bottom 240 mm dia |
| 3 | Erection of Metallic pole of following length in cement concrete 1:3:6 (1 cement :3 coarse sand:6 graded stone gragate40mm nominal size) foundation including excavation and refilling etc. as required. |
| 4 | Excavation including refilling as required |
| 5 | Cement concrete 1:3:6 (1 cement: 3 coarse sand: 6 graded stone aggregate 40 mm nominal size). |
| 6 | Fixing halogen/metalhalide/SVL/IL/LED flood light fitting over existing pole/wall ceiling including clamps, bolts, nuts and wiring using suitable capacity wires. |
| 7 | Supplying and fixing angle iron framework fabricated out of M.S. angle iron and M.S. Flat......with bolts, washers etc., and painted with 2 coats of red oxide and then two coats of approved paint. |
| 8 | 75 x 75 x 6 mm |
| 9 | Supplying of 4cx4 sq sqmm Al Armoured XLPE cable |
| 10 | Supplying and drawing Flexible Multicore Cable manufactured with electrolytic grade flexible copper with low conductor confirming to IS8130-1984 and (Virgin)PVC insulation sheathed suitable for working voltage upto 1100 Volts as per IS-694:1990. |
| 11 | 3C x 1.5 mm2. |
| 12 | Laying of 1 to 4 number of 10 sqmm pvc insulated and PVC sheathed/ XLPE power cable of 1.1 KV grade of following size direct in ground including Excavation and refilling the trench etc as required but excluding sand cushioning and protective covering up tp 35 sqmm. |
| 13 | Laying and fixing of 1 to 4 number of 10 sqmm PVC insulated and PVC sheathed / XLPE power cable of 1.1 KV grade of following size on cable tray as required UP to 35 mm (clamped with 1mm thick saddle). |
| 14 | Supplying and making end termination with brass compression gland and aluminium lugs for following size of PVC insulated and PVC sheathed / XLPE aluminium conductor cable of 1.1 KV grade as required. |
| 15 | 4cx4sqmm (28mm). |
| 16 | Supplying and laying of following size DWC HDPE pipe ISI marked along with all accessories like socket, bend, couplers etc. conforming to IS 14930, Part Il complete with fitting and cutting, jointing etc. in the existing trench, complete as required. |
| 17 | 32 mm dia (OD-40mm & ID-32 mm nominal) |
| 18 | Fixing of Existing outdoor type street light floor mounted panels including connections & floor mounting with concrete. |
| 19 | Supply and fixing of 5A to 32 A rating 240/415V 10KA 'C' curve miniature circuit breaker suitable for inductive load of following poles in the existing MCB DB complete with, connections, testing and commissioning etc. as required. |
| 20 | SP MCB for inside pole |
| 21 | Tripple pole |
| 22 | Supplying and fixing Microprocessor based Electronic timer (without contactor, Din Mounting using necessary bolts, nuts and washers etc.,.)3-120sec setting. |
| 23 | Supply and laying of underfloor(concealed raceways manufactured from 1.5 mm thick cover and base (including partitions for multi-compartment raceways ),zero spangle pre-galvanized sheet steel with 275 GSM(36.67microns) coating mass, cover and base MIG welded together the length of raceways shall be 2.5meters per length with single accessories acting as duct connector including fastening clamps and vertical access boxes and with all required connected accessories complete and load bearing capacity in line with EN 50085-2-2. |
| 24 | 75 x 38 x 2500mm, 1 compartment. |
| 25 | Earthing With GI pipe 4.5 meter long,40mm dia including accessories and providing masonry enclosure with cover plate having locking arrangements and watering pipe etc. with charcoal/coke & salt as required. |
| 26 | Supplying and fixing of 6 SWG GI wire on Surface or in recess for loop earthing as required. |
| 27 | Hiring and running Charges of Crane 20 tons for fixing the flood lights. |
| 28 | Miscellaneous (for rectification panel, doors, wiring, powder coating painting etc.). Please Enable Macros to View BoQ information |
