|
| 1 | GENERAL SUMMARYNOTE: Schedule ‘A’ Part - I to IV are prepriced by MES under Ser No. 2.00to 5.00. Bidders shall insert their lumpsum amount in the Green coloured field under Col-7 only. |
| 2 | Lumpsum price worked out by the contractor for “BUILDINGS / STRUCTURES ” as listed in Schedule ‘A’ Part - I |
| 3 | Lumpsum price worked out by the tenderer for \"PILE FOUNDATION\" as listed in Schedule ‘A’ Part-II |
| 4 | Lumpsum price worked out by the tenderer for \"INTERNAL ELECTRIFICATION\" as listed in Schedule ‘A’ Part-III |
| 5 | Lumpsum price worked out by the tenderer for \"WATER TREATMENT PLANT\" as listed in Schedule ‘A’ Part-IV |
| 6 | SCHEDULE \"A\" PART - VMISCELLANEOUS ITEMSNOTE:Schedule ‘A’ Part - V is not prepriced by MES and prepriced rate indicated as 0.00 under Col.5 signifies this fact only. Bidder shall insert their rates in Green colour filled under Col-7. |
| 7 | Ponit wiring with 1.5 sqmm FRLSH PVC insulated and unsheathed copper conductor multistranded 1100 volts grade, ISI marking drawn through and inculding rigid non metallic PVC 20mm dia concealed conduit and conduit accessories, medium grade, ISI marking, concealed including provn of pre fabricated galvanised module box of 2 mm thick of suitable size as required at site for fixing switches, sockets, inculding one run of 1.5 sqmm PVC insulated unsheathed copper cable for earth continuity, connected to earth duly complete all as specified and directed for the following: |
| 8 | (a) One lightpoint controlled by one switch |
| 9 | (b) One fan (Ceiling/Wall/Exhaust fan) point controlled by one switch |
| 10 | (c) One 3 pin socket outlet 5 Amps socket on Independent board |
| 11 | All as per Item No. 7 here-in-before but One3 pin socket outlet 15 amps socket on independent board with 2.5 sqmm FRLS PVC wire and one run of 2.5 sqmm copper cable for earth continuity. |
| 12 | M & L for Earthing complete with galvanised steel plate electrode, 600 x 600 x 6 mm thick, buried directly in ground (earth pit not less than 2.25 mtrs deep below nominal ground level) with top edge of the plate not less than not less than 1.5 metres below nominal ground level connected to earthing lead of 4 mm dia galvanised iron or steel wire all as shown in plate No. 3 of SSR PART 1 of 2009 to the earthing test point all as specified and as directed.Note :- the cost of excavation and earth work PCC pit and RCC cover funnel & watering pipe, wiremesh, charcoal dust and common salt earth lead protection pipe upto 7.5 Rmt shall be deemed included in the unit rate for earthing all as specified and as directed. |
| 13 | Supply & Fixing in replacement bldg security light luminaries including 45 watts LED street light for 220-230V, 50 Hz with IP 65 protection including bracket for fixing in wall, made of 25mmbore light grade GI pipe connecting up with three core twisted flexible copper conductor cable complete all as specified and directed |
| 14 | M & L for carrying out initial compressive load test on 450mm dia pile as per IS-2911 part-IV complete all as specified and as directed. |
| 15 | M & L for carrying out routine compressive load test on 450mm dia pile as per IS-2911 part-IV complete all as specified and as directed. |
| 16 | M & L for carrying out routine lateral load test on 450mm dia pile as per IS-2911 part-IV complete all as specified and as directed. |
| 17 | M & L for carrying out low strain integrity test on cast in situ piles 450mm dia including analysing the result as per ASTM D 5882 complete all as specified and as directed. |
| 18 | Supply , fix, test and commisioning Water filteration plant with Nano technology having treated water capacity of 250 KLD following parameters : Feed Flow : 10.50m3/hr Operating Hours : 24 Hours , Plant Recovery : 70% with Borewell water as feed water. The treated water must have following characteristics : odour-unobjectionable, pH:6.5-8.5, TDS <500 mg/l, total hardness < 200 , turbidity < 0.1.The Plant shall have following systems : - Duel Media Filter Pump, Duel Media Filter (DMF), Antiscalant Dosing Pump, Cartridge Filter Housing, High Pressure Pump, NF Membrane, Membrane Housing, Skid, Booster Pump, UV System, PH Dosing System. Briefdetail of the system are given below :-1.Duel Media Filter Pump :Qty. : 02 (1W+1S) Capacity : 15 m3/hr, Head 25 mtr Type : Horrizontal Centrifugal Monoblock Pump, MOC : CI. confirming to IS 11401-1 IS 8419 (Part-1), 2. Duel Media Filter (DMF) : Qty : 01 Set, Capacity : 15 m3/hr, Size : 1000 mm dia X1500mm HOS, Pressure 3-4Bar, MOC : MSEP Filteration Media : Fine Sand and Activated Carbon.3. Antiscalant Dosing Pump : Qty : 02 (1W+1S), Type : Electronic Metering Pump, Flow Rate : 0 – 6 LPH, Discharge Pressure : 3-4 kg/cm2,also confiming to IS 9222-1Dosing Tank : 01 No Dosing Tank MOC : HDPE/LDPE, Capacity : 100 Lt. 4.Cartridge Filter Housing : Qty. : 02 (1W+1S), Capacity : 15 m3/hr, Head : 90 mtrs, Type : Vertical Multistage Pump, MOC : CI, Filteration : 5 Microns. also confirming to IS 8419(Part-I) |
| 19 | Item No. 15 contd…..5.High Pressure Pump :Qty. : 02 (1W+1S) Capacity : 15 m3/hr, Head 80 mtr Type : Vertical Multustage Pump, MOC : CI.6. NF Membrane : Qty. : 20 to 25 Nos Dia of membrane : 8\" Length of membrane : 40 Inch. also confirming to IS 8419(Part-I)7. Membrane Housing : Qty. : 3 to 4 Nos, Type : Horrizontal, Diameter : 8\", MOC : FRP, Pressure Rating : 300 PSI. also confirming to IS 8419(Part-I)8. Skid:Qty. : 1 No, Type : Fabricated.9. Booster Pump :Qty. : 02 (1W+1S) Capacity : 11.5 m3/hr, Booster Pressure : 2 Bar Type : Vertical Multistage Pump. MOC : CI. 10. UV System :Qty. : 01, Capacity : 10.50 m3/hr, MOC : SS. also confirming to 14724 : 199911. PH Dosing System : Qty. : 02 (1W+1S), Type : Electronic Metering Pump, Flow Rate : 0 – 6 LPH, Discharge Pressure : 3-4 kg/cm2,also confirming to IS 9222-1Dosing Tank : 01 No Dosing Tank MOC : HDPE/LDPE, Capacity : 100 Ltr12. Other Items :Electrical Panel, Power and Control Cable, Inter connecting Piping Fitting And Valves, Pressure Gauge, Low pressure Switch, High pressure Switch, pH Meter, TDS Meter, ORP Meter. |
| 20 | Item No. 15 contd…..13.1: Electricalitems: 1. Non-Compartmentalised, fixed type, Sheet thickness – 2.0 mm.2. Cable entry –Top/Bottom3. All Bus bars – Aluminium4. Incomer – 1 No.Incomer shall consist of following componentsa. MCCB, 415 Volts – 1 No.b. Ammeter with selector switch – 1 setc. Voltmeter with selector switch – 1 setd. Supply ON indication lamps – 3 Nos.5. DOL starter (up to 7.5 KW)DOL starter shall consist of following components:a. TPMPCB – 1 No.b. Power contactor – 1 No.c. Push button with 1 element – Stop & Startd. Indication lamps – on & off6. Star delta starter (above 7.5 kw)Star delta starter shall consist of following components:a. TPMCB – 1 No.b. Power contactors – 3 Nos.c. Timer – 1 No.d. Push button with 1 element – Stop & Start.e. Indication lamps – on & off7. Control Supply – SP MCBs – as required for instrument supply.8. Power wiring – minimum 2.5 sq.mm PVC insulated copper wire.Control wiring – 1.5 sq. mm PVC insulated copper wire Control supply – 1ph, 230 VAC obtainedfrom phase and neutral. |
| 21 | Item No. 1 contd…..13.2.: CABLES13.2.1: Power cables : XLPE armoured, Stranded Aluminium conductor cables as per IS 7098(part-1). Minimum power cable size shall be 3c x 2.5-sq. mm13.2.2: Control cables : XLPE armoured, Stranded Aluminium conductor cables as per IS 7098(part-1). Minimum power cable size shall be 1-sq. mm13.2.3 : MOTORS : Motors shall be as per IS 325, totally enclosed, fan cooled squirrel cage induction motors. Degree of protection shall be IP55. Motors shall be suitable for supply voltage of 415 volts 10% and frequency of 50 Hz. 5%, and combined variation 10%.Note 1 : The quoted rate shall be included forAll civil work including foundations/ Platform, puddle Pipe, inserts, plates, pipe supports etc. to any other work required to complete the job.Note 2 : The contractor will be responsible for comprehensive maintenance of the water filtration plant during the defect laibility period, including change/replacement of any internal item required for maintenance of the plant inorder to maintain the desired water quality parameters as mentioned in the item. Rate for the same will be deemed to be included in Lumpsum. No additinal payment will be considered for the comprehenisve maintenance during the DLP period. |
| 22 | M & L for earthing complete with copperplate earth electrode 600X600X3.15 mm thick buried directly in ground (earth pit not less than 2.25 meter below ground level) with top edge of the plate not less than 1.5 metre below normal ground level connected to copper strip 20X3mm at two points by means of bolts and nut, check nut and washers including charcoal dust, common salt, necessary excavation in hard/dense soil, returning filling in and removal of surplus soilto a distance up to 50metres, PCC pit in 1:3:6 type C1 (using 20mm grade stone aggregate) RCC 1:2:4 type B-1 (using 20mm grade stone aggregate ) 50mm thick pit cover, reinforced with 8mm dia TMTbars 75mm c/c, both ways MS handle 12mm dia, GI funnel, wire mesh and GI watering pipe of 20mm bore GI (light grade) and earth leadprotection pipe 25mm bore (light grade) all as specified, directed and shown in electrical plate No 3 of SSR Part-I including testing complete. Note :copper strip and protection pipes 25 mm GI light grade up to 7.5 metre is included in unit rate and beyond that the same will be measured separately. |
| 23 | Spreading, leveling, compacting of riddled earth obtained from trenchesfor cable cushioning on top and bottom of cablecomplete all as specified and directed. (Note: Only punned thickness of riddled earth shall be measured) |
| 24 | Supply and fix PVC Tank 10000 ltrscapacity , three layered, made of virgin polymer granules, Anti microbial ,Anti Bacterial , Food Grade Polymer with FDA Approval,Phthalate Free Polymer Granules & Additives , 100% UV Stabilized Tank , UV Stabilized Lid , preferably green colour and making connection to raw waterincoming pipe linecomplete all as specified and directed. |
| 25 | Supply and laying GI pipe of 80mm dia Medium garde including fittings on walls/under floors/road crossings/in trenches all as specified and directed. |
| 26 | Supply and fixing sluice valve of size 80mm dia class PN 1.6 complete all as specified and directed. |
| 27 | SIGNATURE OF CONTRACTOR |
