Tender For Special Repair Work Of Syana Eklandi Hingwada Wahpur Kuchesar Road (Odr) - Providing, laying, spreading and compacting stone aggregates of specific sizes to water bound macadam specification including spreading in uniform thickness, hand packing, rolling with 3 wheeled steel/ vibratory roller 8-10 tonnes in stages to proper grade and camber, applying and brooming requisite type of screening/ binding Materials to fill up the interstices of coarse aggregate, watering and compacting to the required density.Including all taxes, royalties, supply of all materials,labours, tools & plants etc. required for proper compeletion of the work.(All compelete but excluding G.S.T.) 2 Providing and applying tack coat with bitumen VG-10 grade using bitumen pressure distributor at the rate of 0.30 kg per sqm on the prepared bituminous/granular surface cleaned with mechanical broom.Including all taxes, royalties, supply of all materials,labours, tools & plants etc. required for proper compeletion of the work.(All compelete but excluding G.S.T.) 3 Providing, laying and rolling of open - graded premix surfacing of 20 mm thickness composed of 13.2 mm to 5.6 mm aggregatesusing Viscocity grade bitumen to required line, grade and level to serve as wearing course on a previously prepared base, including mixing in a suitable hot mix plant of appropriate capacity not less than 200 tonnes/hour, laying and rolling with a smooth wheeled roller, finished to required level and grades.Including all taxes, royalties, supply of all materials,labours, tools & plants etc. required for proper compeletion of the work.(All compelete but excluding G.S.T.) 4 Providing and laying of premix sand seal coat with HMP of appropriate capacity not less than 75 tonnes/ hours using crushed stone chipping 6.7 mm size and penetration bitumen of suitable grade.Including all taxes, royalties, supply of all materials,labours, tools & plants etc. required for proper compeletion of the work.(All compelete but excluding G.S.T.) 5 Construction of embankment with approved material obtained from Right of way pits with all lifts and leads, transporting to site, spreading, grading to required slope and compacting to meet requirement of table 300-2. (3.16) MORT&H Specification 305 Sr No 3.16.Including all taxes, royalties, supply of all materials,labours, tools & plants etc. required for proper compeletion of the work.(All compelete but excluding G.S.T.) 6 Construction of un-reinforced,dowel jointed, plain cementconcrete pavement over a prepared sub base with approve grade cement @ 400 kg per cum, coarse and fine aggregateconforming to IS 383, maximum size of coarse aggregate not exceeding 25 mm, mixed in a batching and mixing plant as per approved mix design, transported to site, laid with a fixed form or slipform paver, spread, compacted and finished in a continuous operation including provision of contraction, expansion, construction and longitudinal joints, joint filler, separation membrane, sealant primer, joint sealant, debonding strip, dowel bar, tie rod, admixtures as approved, curing compound, finishing to lines and grades as per drawing Including all taxes, royalties, supply of all materials,labours, tools & plants etc. required for proper compeletion of the work.(All compelete but excluding G.S.T.) 7 Construction of sub-grade and earthen shoulders with approved material obtained from borrow pits with all lifts & leads, transporting to site, spreading, grading to required slope and compacted to meet requirement of table No. 300-2. MORT&H Specification 305 Sr No 3.18Including all taxes, royalties, supply of all materials,labours, tools & plants etc. required for proper compeletion of the work.(All compelete but excluding G.S.T.)
