Tender For Up gradation Of Water Filtration Plant At Palchan Under Age (I) R And D Manali; 1 Supply, installation, testing and commissioning of ACTIVATED CARBON FILTER with UV System having Epoxy Coated Pressure vessel with Set of frontal pipe work and valves Set of internal water distribution and collection system& Pressure gauge to monitor head loss across the filter with Orifice board for indicating wash water flow to be fitted in drain sump to remove dirt, dust, silt, sand, insects, fibre, odour colour and other organic matters etc of the following specification:-Dia. :- 1800mmHOS:- 1875mmFlow rate :-61 m3/hrShell:-5mmDish End :6mmFrontal Pipe Work:100mmCarbon Depth :-1000mmCarbon Qty. :- 2.54 m3MOC :-MSEP 2 Supply , installation,test and commissioning of 5 HP Three Phase Copper Winding Centrifugal Monoblock Pump, 50X40mmwith 42 m head,complete including provision of necessary foundation for pump sets connected to suction and delivery etc complete with provision of following all as specified and directed by Engg - in- charge:- Make : Kisloskar, CG, KSB 3 Supply, installing, testing and commissioning factory made LT ( 415 Volts, 50 Hz , 3-phase, 4 wire supply ) CPRI approved, factory assembled LT Panel Outdoor type, platform mounted, suitable for 415 Volts 3 Phase and neutral, 4 wire, 50Hz AC supply system having bus bar chamber with insulated Aluminium bus bars of 100 Amps rating installed on DMC insulators with bus bar chamber. The panel shall be dust and vermin proof, ingress protection class ( IP-54 ) and made of 3.15 mm thick CRCA mild steel sheet and mild steel, Angle iron frame work made out of 50 X 50 X 6 mm ), front and rear opening type with proper ferrule & cable gland, internal wiring with PVC insulated multistranded copper conductor FR wire of adequate size but not less than 1.5 sqmm complete. All steel metal works including frame shall be with anticorrosive coating with seven tank process and finally epoxy polyester powder coating of Siemens grey shade 7035. embedded in ground with and including bocks of PCC 1:2:4 type B1 of block size 30x30x30 cm comprising of the following:- 4 BUS BAR CHAMBER :- (a) 100 Amp 4 StripsAluminium conductor, with color coded heat shrinkable sleave and shall be mounted on non hygroscopic, non combustible, track resistant, high strength DMC material, interconnection of all incomings & outgoings.INSTRUMENT CHAMBER :- (a)Digital Volt Meter, 96X96mm, flush type rated 0-500 V, with Volt meter selector switch- 01 Set. (b) Digital Amp Meter, 96X96mm, flush type rated 0-100 A, with Amp meter Selector switch- 01 Set.(c) C.Ts 100/5 A CL 1.0 Tape Wound- 01 Set. (Set of three)(d) Red, Yellow, Green Phase indicating Lights LED type 220 V AC- 1 Set. (Set of three).(e) Protection MCB 6 A SP C Series- 1 Set. (Set of three). Make of Metering Accessories :-L&T/ AE/ Trinity/ Schneider.INCOMING SUPPLY :-(i) MCCB 100 Amps 25 KA 4 Pole with Adjustable thermal & fixed magnetic release 415 volts , 50Hz,=01 No., Make of MCCB:-L&T/ Siemens / Legrand/ HPL/Havells. 5 OUTGOING SUPPLY :- 1. DOL Starter 5 H.P. Each having the following :- 2 Nos. (a) MCB 32 A 10 KA TPN, 415 volts , 50Hz - 01 No (b) Power Contactor 18 A TP 220 V AC- 01 Nos.(c) Bi Metal Over Load relay 9-15 A - 01 No.(d) Auto Phase Sequence Corrector 5 HP- 01 No.(e) Push button Start/Stop with Elements - 02 Nos, (f) Auto manual selector switch - 01 No.(g) On, Off, Trip indicating Lights LED type 220 V AC- 1 Set. (Set of three).(h) Control MCB 6 A SP - 1 No.Make of Starter accessories :-L&T/ ABB/Legrand / Schneider/Trinity/AE. 6 The panel manufacturer should have following Govt. Approved Certificates: 1. Panel should be according to IEC-61439. CPRI Certification Degree of Protection IP-54(IS/IEC : 61439 (Part-1), 2011& IS/IEC : 61439 (Part-2) 2011)2. Tempreature Rise (IS/IEC : 61439-1, 2011 & IS/IEC : 61439-2 2011)3. CPRI Short Circuit IEC-61439-1 & 2 withstand strenght should be 70kArms for 1.0 Sec with intial peak of 154kApk4. CPRI Certification IEC-61439-1 & 2 Rated current for short circuit not less than 6300 A with rated insulation voltage 660V5. ISO 9001 CERTIFIED
