Major Repair (Construction Of toilet At Ms Gowar)Pyt. Surjan Chakblock Duggan Under Scheme Samagra Shiksha Approved Under Pab For The Year 2025-26- 1 Earth work in excavation by manual means in trenches for foundations, drains, pipes, cables etc. (not exceeding 1.5 m in width) and for shafts, wells, cesspits and the like not exceeding 10 sqm on plan, including dressing of sides and ramming of bottoms lift upto 1.5 m, including getting out excavated earth and disposal of surplus excavated earth as directed: All kinds of soil 2 Providing and lying in position cement concrete 1 cement:5 fine sand:10 graded crushed stone aggregates 40mm size.excludingthe cost of centring and shuttering all work upto plinth Level 3 Providing and laying in position cement concrete 1 cement:3 fine sand:6 graded crushed stone aggregates 20mm size excluding the cost of centring and shuttering- all works upto plinth level. 4 Providing and laying damp-proofCourse 50 mm thickwith cement concrete 1:2:4 (1 cement:2 coarse sand: 4 graded stone aggregate 20 mm nominal size) and curing complete 5 Centering and shuttering including strutting, propping etc. and removal of form for:Foundations, footings, bases of columns etc. for mass concrete. 6 Centering and shuttering including strutting, propping etc. and removal of form for: Suspended floors, roofs, landings, balconies and access platforms. 7 Centering and shuttering including strutting, propping etc. and removal of form for: Edges of slabs and breaks in floors and walls Under 20 cm wide 8 Providing and fixing 1mm thick M.S. sheet door with frame of 40x40x6mm angle iron and 3mm M.S. gusset plates at the junctions and corners, all necessary fittings complete, including applying a priming coat of approved steel primer.Using M.S. angles 40x40x6mm for diagonal braces 9 Brick work with F.P.S. bricks ofclass designation 75 in foundation and plinth in:1cement : 6 coarse sand mortar. 10 Extra for brick work with common burnt clay bricks/cement concrete bricks in superstructure abov 11 Reinforced cement concrete work in beams, suspended floors, roofs having slope upto 15°, landings, balconies, shelves, chajjas, lintels, bands, plain window sills, staircases and spiral stair cases upto five level including curing but excluding the cost of centring, shuttering, finishing and reinforcement with1:1½:3 (1 cement : 1½ coarse sand : 3 graded stone aggregate 20 mm nominal size) 12 Providing and laying in position specified grade of reinforced cement concrete including curing but excluding the cost of centering, shuttering, finishing and reinforcement. All works upto plinth level 1 cement: 2 coarse sand : 4 graded stone aggregates 20mm nominal size. 13 Steel reinforcement for R.C.C. work including straightening, cutting, bending, placing in position and binding all complete upto plinth level Mild steel and medium tensile steel bars 14 12 mm Cement plasteron the rough side of single or half brick wall of mix: 1 : 6 ( 1 cement : 6 fine sand) 15 15mm thick cement plaster of 1 cement: 6 fine sand mix. 16 6mm cement plaster to ceiling of mix 1:3 17 Filling available excavated earth (excluding rock) in trenches, plinth, sides of foundations etc. in layers not exceeding 20 cm in depth, consolidating each deposited layer by ramming and watering, lead upto 50 m and lift upto 1.5 m 18 Providing and laying/fixing ceramic Glazed Floortiles 300X300mm (thickness to be specified by the manufacturers) of 1st quality conforming to IS : 15622 of approved makein all colours and shades, laid on 20 mm thick cement mortar 1:4 (1 cement : 4 coarse sand) including grouting the joints with white cement and matching pigment etc., complete. 19 Providing and fixing Ist quality ceramic glazed wall tiles conforming to IS : 15622 (thickness to be specified by the manufacturer), of approved make, in all colours, shades except burgundy, bottle green, black of any size as approved by Engineer- in-Charge, in skirting, risers of steps and dados over 12 mm thick bed of cement mortar 1:3 ( 1 cement : 3 coarse sand) and jointing with grey cement slurry @ 3.3 kg per sqm, including pointingin white cement mixed with pigment of matching shade complete. 20 Distempering with oil bound washable distemper of approved brand and manufacture to give an even shade on new work (two or more coats over and including priming coat with water thinnable cement primer) 21 Finishing walls with water proofing cement paint of required shade on New work (two or more coats applied @ 3.84 kg/10sqm) 22 Providing and fixing water closet squatting pan (Indian type W.C. pan) with 100 mm sand cast Iron P or S trap, 10 liter low level white P.V.C. flushing cistern, including flush pipe (of approved make) with manually controlled device (handle lever) conforming to IS: 7231, with all fittings and fixtures complete, including cutting and making good the walls and floors wherever required.White vitreous china Orissa pattern W.C. pan of size 580x440 mm with integral type foot rests. 23 Providing and fixing wash basin with C.I. brackets, 15 mm CP pillar cock, 32 mm CP waste coupling of standard pattern, including painting of fittings and brackets, cutting and making good the walls wherever required. White Vitreous China Flat back wash basin size 550x400 mm with single 15 mm CP Pillar cock. 24 Providing and fixing white vitreous china pedestal for wash basin completely recessed at the back for the reception of pipes and fittings. 25 Providing and fixing G.I pipe to IS ( MediumClass) with fitting upto 150mm dia & above shall be MS 7mm thick confirming to IS : 3989 including Synthetic enamel paints of approved quality and shade over a coat of approved priming coat ( Shade as per colour code ) and clamps and flange including cutting & making good walls complete.(internal and Exposed on walls)& includes testing of joints.20mm Dia Pipe 26 Providing and fixing G.I pipe to IS ( MediumClass) with fitting upto 150mm diad & above shall be MS 7mm thick confirming to IS : 3989 including Synthetic enamel paints of approved quality and shade over a coat of approved priming coat ( Shade as per colour code ) and clamps and flange including cutting & making good walls complete.(internal and Exposed on walls) & includes testing of joints.25mm Dia Pipe 27 Providing and Fixing of G.I/PVC fittings. 75 mm PVC Pipe 28 Providing and Fixing of G.I/PVC fittings. 110mm Dia PVC Pipe 29 Providing and Fixing of G.I/PVC fittings. 110mm Plain Bend 30 Providing and Fixing of G.I/PVC fittings. 75mm plain Bend 31 Providing and Fixing of G.I/PVC fittings. Floor Trap 75mm Dia 32 Providing and Fixing of G.I/PVC fittings. Floor Trap110mm 33 Providing and Fixing ofPVC Bal value 20mm 34 Providing and Fixing of20mm Tank Nipple 35 Providing and Fixing of Soap Dish 36 Providing and Fixing of Bevelled LookingGlass (600x450)mm 37 Providing and placing on terrace (at all floor levels) polyethylene water storage tank ISI : 12701 marked, with cover and suitable locking arrangement and making necessary holes for inlet, outlet and overflow pipes but without fittings and the base support for tank 38 Providing and fixing 15 mm nominal bore C.P. brass bib cock of approved quality conforming to IS : 8931 39 Providing and fixing 15 mm nominal bore C.P. brass angle valve for basin mixer and geyser points of approved make conforming to IS : 8931 40 Providing and fixing Cpgrating of approved quality 100 mmofnominal dia 41 Providing and fixing on wall face un-plasticized Rigid PVC rain water pipes conforming to IS: 13592 Type A including jointing with seal ring conforming to IS: 5382 leaving 10 mm gap for thermal expansion. Single socketed pipes 75 mm diametre 42 Providing and Fixing of white vitrous china clay half stall urinal flat back 580x380x350 mm or angle back 450x375x350 mm with waste fittings as per IS:2556 43 Providing and Fixing of GI flush pipe and C.P. brass spreader including C.P connecting pipe range of two lipped urinals 44 Providing and Fixing of white viterous Chinna Urinal Partition plate Size 160x400x825mm Including Fittings.two lipped urinals 45 Wiring for light point/ fan point/ exhaust fan point/with 1.5 sq.mm FRLS PVC insulated copper conductor single core cable in surface / recessed medium class PVC conduit, with modular switch, modular plate, suitable GI box and earthing the point with 1.5 sq.mm FRLS PVC insulated copper conductor single core cable etc. as required. 46 Carriage of Sand an Avg. Lead 90 Km by M.T and 400 m HL 47 Carriage of Agg. an Avg. Lead of 90 Km by M.T and 400 m HL 48 Carriage of Bricks an Avg. Lead of 160 Km by M.T and 400 m by HL
