|
| 1 | S & F Steel tubular swaged poles, 9 meters long complete with cast iron base plate, finial taper plug, bolts, nuts & screws as specified type 410 SP-31 inclusive of one primer coat of red oxide zinc chrome primer and two coats of aluminium paint including preparation of surfaces and writing Pole No complete all as specified and directed by Engr-in-Charge.Make:IndiaTube&Co,India Electric Poles,National Tubing Co.Note : (i) Design/Drawing/BOM of pole is to be obtained from the Maufacturer/Authorised supplier and the same is to be got approved from Engr-in-Charge prior to making order to the Manufacturer/Supplier.(ii) Earth work and PCC shall be measured & paid separately. |
| 2 | Supply, fix and testLED Flood light fittingssuitable for fixing on poles any type, of capacity 120 Watts, CRI>70, Power factor >0.95 colour temperature 5700K, luminous Efficacy not less than 100 lumens/watt, colourtemperature 5700K, 12000 lumens output, IP-66 including electronic driver (SMPS based constant current supply with lower THD, output open/short circuit protection, phase to phase protection, over voltage protection, surge voltage protection etc) unit suitable for working voltage 140-270VAC, 50 Hz pressure die cast aluminium housing and finishing epoxy powder coated with all accessories as per manufacturer\"s instructions and connecting up ncluding necessary fixing arrangement, in the form of MS Clamps,Cross arms, bracing,Supports completeall as specified and directed. Make: Havells, Cat No:JETA JETAIRISFLS120WLED757APWBLTG ortechno-commercially equivalent in Philips/Wipro |
| 3 | S&F loop in- loop out fuse junction box (CPRI type tested) of internal dimension 300x200x100 mm made out of FRP sheet with weather proof canopy and locking screw fitted with and incl 10 Amps, C Curve, 10KA breakinng capacity SP MCB - 1 No, 50 Amps rated 4 Way connectors for 3 phase and neutral incoming/out going, mounted in the box, fixing on steel tubular/Rail poles including necessary aluminium clamps, suitable cable glands, lugs and GI nut and bolts complete all as specified and directed. |
| 4 | Supply and laying light grade GI pipe (ISI Marked) of size 40 mm for cable protection to be fixed on wall/pole/Road Crossing with necessary clamps as per existing or in road crossing ccomplete all as specified and directed.Note :- Unit rate quoted rate is deemed to be inclusive of MS clamps if required to be fixed on pole/Wall. |
| 5 | Supply and fixing Medium gradePVC Conduit (ISI Marked) of size 20 mm for cable protection to be fixed on wall/pole with necessary Aluminium clamps in wall/poles complete all as directed and specified by Engr-in-ChargeNote :- Unit rate quoted rate is deemed to be inclusive of Aluminium clamps if required to be fixed on pole/Wall. |
| 6 | Supply, laying, connecting and testing cable XLPE Insulated ,screened, PVC bedded, galvanized steel strip or wire armoured, electric power cable (heavy duty) 1100 Volts grade with stranded aluminium conductor of size 16 sq mm 4 core in trenches / through GI pipe / fixed along with pole structure etc with all fixing & connecting accessories complete all as specified and as directed. |
| 7 | Supply, laying, connecting and testing of PVC insulated flexible multicore round copper conductor cable of size 3 core 1.5 Sqmm including necessary end connector fixed along with pole structure etc with all fixing & connecting accessories complete Make:Havells, Cat No: WHMFDSKB31X5 or equiv in KEI/Polycab all as specified and directed. |
| 8 | Supply,fix and testing of Control panelfactory fabricated (CPRI type-tested) 6.0KW with MCB SPN 40 A, contactor 32 A, Digital Timer Control Panel, outdoor type including connected switch gears, cables, etc. and suitable sheet metal enclosure test and commisioning of Panel of 240V, out door(IP-54) cubical type with suitable provision of 25x25x3mm angular base and vertical frame along with necessary PCCfoundation and locking arrangement incl taking down old unsv one complete all as specified and directed. Make :Havells,Cat No:IHXSS01060Note:- The quoted rate shall be inclusive of the following:-(i) Suitable copper control wiring inside Panel boards, cable glands, cable lugs, supporting, insulators etc., (ii) Quoted rate is inclusive of angular base frame and PCC foundation Earth work and connected accessories. (iii) Design / drawing / BOM of the panel showing the dimensions is to be obtained from Manufacturer / Supplier & is to be got approved from the GE before placing final order to the manufacturer. (v) Anything missed out in the technical specifications but technically required for efficient working is deemed to be included in the quoted rates. |
| 9 | M & L for cutting the existing hard standing/PCC/WBM road at adepth not less than 45 cm and 25 cm in width for passing of cable through GI pipe, returning filling in, complete including finishing the surfaces by providing top 30 mm thick cement concrete type B-1 (1:2:4) using20 mm grade aggregate, bottom filled with excavated earth and remain finishing to a unifirm smooth surface complete all as specified and directed. |
| 10 | M&L for PCC 1:2:4 type B1, using (20mm graded stone aggregate) for coping of poles including necessary form work etc complete all as specified and directed by Engr-in-Charge. |
| 11 | M&L for providing PCC 1:3:6 type C1, Using 40mm graded aggregate for Cement concrete in foundations, filling and mass concrete including necessary form work etc complete all as specified and directed. |
| 12 | Excavation in trenches n.exc 1.5 m wide and n.exc 1.5m depth for errection of poles, laying of cables etc and getting out in hard/dense soil complete all as specified and directed. |
| 13 | Returning, filling in, including spreading levelling, watering and well ramming in layers not exc 25 cm in thick using excavated soil all as specified and directed. |
| 14 | Removing excavated material to a distance not exc 50 mtrs and depositing where directed at a level n.exc 1.5 mtr above the starting point. |
| 15 | Supply and laying well burnt old size sub class \"B\" bricks of size 230mm x 115mm x 75mm bricks in trenches for cable protection of U/G cables all complete all as specified and directed |
| 16 | Supply, spreading and levelling of approved riddled earth as approved by GE in trenches for cable cushion on both top and bottom of cable, including ramming all as specified and as directed. |
| 17 | M & L for surface sub-main wiring alongwith earth wire of size (2 x 4.0) sq. mm + (1 x 4.0) sq. mm earth wire, ISI marked, FRLS, PVC insulated, multi stranded, copper conductor, single core cable drawn through and including non-metallic PVC casing-caping with all fittings and accessories ISI marked for conduits & sinkings for modular boxes & making good to walls, floors etc. complete all as specified & as directed. Make of cable : Havells/Polycab/Finolex. Make of Casing-caping : Press-fit/Precision/Modi |
| 18 | M & L for Surface sub-main wiring alongwith earth wire of size of (4 x 10.0 sq. mm + 1 x 10.0) sq. mm earth wire, ISI marked, FRLS, PVC insulated, multi stranded, copper conductor, single core cable drawn through and including non- metallic rigid PVC medium grade Casing-capping and accessories ISI marked of appropriate size/thickness on walls/other surface etc. incl making good the disturbed surfaces as per original complete all as specified and as directed.Make of cable : Havells/Polycab/Finolex. Make of Casing-caping : Press-fit/Modi/Precision NOTE for item No 1 & 2 : (i) Two/four runs of PVC wire, one run of earth wire & one run of casing-capping will be measured as one length. (ii) The wiring shall be done in proper color coding using red,yellow,blue for phases, black for neutral and green for earth. (iii) The cost of making good the disturbed surfaces is deemed to be included in the unit quoted rates. |
| 19 | S & F Modular switch, one way, 16 Amp with Indicator, 1 Module, 240 volt complete all as specified and as directed. Cat No : ACVSXIW161, Model - Verona of make CRABTREE (Havells) or techno-commercially equiv In Legrand/Anchor Roma. |
| 20 | S & F Modular shuttered socket outlet 3 Pin, 6/16 Amp, 2 Module, 240 volts, ISI marked complete all as specified and as directed. Cat No : ACVKCWW163, Model - Verona of make CRABTREE (Havells) or techno-commercially equiv In Legrand/Anchor Roma. |
| 21 | Supply & Fixing PVC surface box flush to wall suitable for fixing switches of 1/2 modules complete all as specified & as directed. Cat No : ACNXMIZX01, Model - Verona of make CRABTREE (Havells) or techno-commercially equiv In Legrand/Anchor Roma. |
| 22 | Supply & Fixingmodular cover platesuitable for fixing switches of 1/2 modules all as directed. Cat No : ACVPPCWV01/02, Model - Verona of make CRABTREE (Havells) or techno-commercially equiv In Legrand/Anchor Roma. |
| 23 | S&F single pole & neutral enclosure with a two pin & earth plug & socket complete with one single pole MCB \"C\" curve of 20 A rating, 10 KA incl making good the disturbed surfaces as per original complete. Make: L&T, Cat No : DBMPS120SDor tech-commercial equivalent in SIEMENS/LEGRAND. |
| 24 | Supply, Fix, Installing and Testing Vertical type Storage electric water heater (Geyser) of 25 Ltrs capacity, Tank made of ultra thick super cold rolled steel plates with high density PUF insulation, 2 KW, 230 V, Single Phase, 50 Hz, AC, BEE 5 Star rated, suitable for a pressure rating of 0.8 MPa Bar with 7 years warranty on inner tank, 4 years on heating element & 2 year comprehensive warranty with & including connected accessories and 2 Nos anchor fasteners of size as per manufacturer instructions grouting and fixing and making good the disturbed surface complete and connecting electrical and water supply connection using steel braided hose 2 Nos complete all as specified and directed by the Engr-in-Charge. Model - BIANCA, Make: Havells, Cat No: GHWCBNTWH025 or techno-commercially equivalent in V-Guard/Bajaj |
| 25 | Note : (i) Installed Geyser\"s warranty card should be submitted to the Engr-in-Charge. (ii)The cost of making good the disturbed surfaces and matching to the existing/original surface is deemed to be included in the unit quoted rates (iii)The cost of taking down old unserviable gyser andtranportation of old gyser to be submittedto MES Store yardis deemed to be included in the quoted rate. |
| 26 | S&F angular stop cock 15mm dia with wall flange screwed both ends for GI Pipe etc., fancy type & chromium plated complete all as specified and as directed by Engr-in-Charge. Cat No : AQT-3057 of make Jaguar or techno-commercially equivalent in Kohler/Cera. |
| 27 | S&F Bib cock 15 mm dia with wall flange screwed for GI Pipe etc., fancy type & chromium plated complete all as specified and directed by Engr-in-Charge. Cat No : CQT-23047 of make Jaguar or techno-commercially equivalent in Kohler/Cera. |
| 28 | M&L for galvanised steel water tubing with all fittings, Medium grade, ISI marked, 15 mm bore, fixed or concealed in walls, laid in floor etc. including all jointing materials complete all as specified and directed by Engr-in-Charge. Make: TATA/Jindal/PrakashNote : 1) The cost of clamping of water tubing on walls/ceilings etc. is deemed to be included in the unit quoted rates. |
| 29 | Imp Notes for Item Nos 19to 25 : 1) Design/Drawing/Technical catalogue/specifications along with comparative Rate Analysis to be submitted to the Engr-In-Charge for Make/Sample approval of items whereever equivalency of Item(s) is concerned other than specified Make/Model/Cat/Part Ref concerned. 2) Cost of making good the disturbed surfaces as per existing/original surface is deemed to be included in the unit quoted rates. |
| 30 | Cutting the existing outlet pipe of size 15 mm dia for making branch connection for and including new tee complete all as specified and directed by Engr-in-Charge. Cost of making good the disturbed surfaces as per existing/original surface is deemed to be included in the unit quoted rates. |
| 31 | S&F MCB DB,DD,TPN 6 Way,415 Volts,IP43,IK-09 with busbar & blanking plates including making good the disturbed surfaces complete all as specified and directed by Engr-in-Charge.Make: L&T, Cat No: DBTPN006DD or techno-commercially equiv in Legrand/ABB/Siemens.(Tele exchange) |
| 32 | Note:- (i) The cost of making good the disturbed surfaces is deemed to be included in the unit quoted rates. |
| 33 | S & F MCB, DB, SPN, 12 ways, DOUBLE DOOR, IP-43, Ik-09 with metal door, rated bus bars, earth bar, neutral links complete incl. blanking plates as required & fixed flush to wall/other surface & making good the disturbed surfaces as per original complete all as specified and as directed. Make : L&T Cat No.- DBSPN012DD or techno-commercially equiv in Legrand/ABB/Siemens. |
| 34 | S&F MCB TPN 63A,10KA,\"C\" Series (Ics=100% of Icu) with adjustable overload & adjustable Short circuit setting complete all as specified & as directed by the Engr-in-Charge.Make: L&T, Cat No BB40630C or techno-commercially equiv in Legrand/ABB/Siemens. |
| 35 | S&F MCB, SP, C-Series 240 Volts of capacity 6-32 Amps with breaking capacity 10 KA all as specified and dircted by Engr-in-Charge. Make : L&T Cat No.- BB10(06-32)0C or techno-commercially equiv in Legrand/ABB/Siemens.NOTE : The Make/Model of MCB DBs & MCBs shall be the same. |
| 36 | Supply, install, commissioning & testing of hi wall, split-type Air Conditioner Unit including R-32 refrigent of capacity 2.0 TR or higher rating based on Inverter Technology, smart 4-way swing, turbo cool, 10 years warranty on compressor,comprising of variable speed copper compressor suitable for adjusting power depending on heat load incl indl indoor & outdoor units complete with cordless remote control unit & with in-built stabilizer free operation & PM 2.5 Filter etc. for better indoor air quality with 5 star rating incl electric connection complete all as specified and as directed. Make : LLOYD, Cat No-GLS24I5FWGEV or tecno-commercially equivalent in Voltas/Hitachi. |
| 37 | NOTE :(i) The Air Conditioner shall be initial filled / charged with refrigerant of specified quantity & the refrigerant to be used shall be Non-CFC type & as per the latest technology. (ii) The cost of additional refrigerant pipes required (if any) is deemed to be included in the unit quoted rates. (iii) Suitable piping of adequate length & size for drainage of condensate water from indoor unit shall be provided & the cost of the same is deemed to be included in the unit quoted rates. (iv) Cost of staging & shed/weather-proof arrangemets required for fixing/ installation of the outdoor units is deemed to be included in the unit quoted rates. (v) Anything missed out in the technical specifications but technically required for efficient working of the AC is deemed to be included in the unit quoted rates. |
| 38 | Supply and fix refrigerators Double Door type, electric driven (single phase), capacity more than 300/310 Litres ,with 10 year warranty oninverter compressor, BEE 3 star rated. incl electric connection complete all as specified and as directed. Make : LLOYD, Cat No.-GLFF313AHGTIPB techno-commercial equivalent in LG/SAMSUNG/Voltas. |
| 39 | NOTE :(i) The Compressure shall be initial filled / charged with refrigerant of specified quantity & the refrigerant to be used shall be Non-CFC type & as per the latest technology. (ii) The cost of additional stand requiredfor keeping the refrigeratoris deemed to be included in the unit quoted rates.iii) Anything missed out in the technical specifications but technically required for efficient working of the AC is deemed to be included in the unit quoted rates. |
| 40 | Supply, install, commissioning & testing of wall-mounted copper wound voltage stabilizer, ISI marked for automatic operation, single phase, naturally air cooled, indoor type & designed for I/P variation between 160 V to 260 V with Digital Voltmeter & O/P voltage stabilization at 230 V with accuracy of +/- 2.5%, with high & low voltage cut off & time delay & of capacity 5.0 KVA suitable for 2.0 TR Inverter AC incl electric connection complete all as specified and as directed. Cat No : VCDW-04160 of make Volina or technocommercially equivalent of Sen & Pandit/V-Guard. |
| 41 | M&L for providing PCC 1:2:4 type B2, Using 40mm graded aggregate for Cement concrete in foundations, filling and mass concrete including necessary form work etc complete all as specified and directed. |
| 42 | Supply and fix mild steelStairs (framed) including stringers, treades, landing, balusters, hand rails etc. including cleats, brackets, etc.complete Fe-410-W(Gde- E-250)quality-B etc complete all as specified and directed. |
| 43 | Supply and fix for framed work as in doors or gates of angle or other section with gusset plates, rails, braces, etc., complete, drilled for fixing of steel sheeting or other covering. Doors, etc. to be prepared for hanging or sliding with and including either hooks and hinges or steel hanging door fittings (exclusive of steel sheeting or other covering,running rails and guides) and hanging; also fastening and fixing complete Fe-410-W(Gde- E-250)quality-A etc complete all as specified and directed. |
| 44 | M & L for PCC 1:2:4 type B1 (using 20mm graded stone aggregate)in padding,coping, bed plates, levelling courses, holdfast blocksand the like including necessary form work weathering, slightly rounded or chamfered angles and throating, as directed. |
