Supply Of Density Measurement Instrument- 1 Internal Water Supplys & F 15 Mm Bore Angular Stop Valve, Half Or Quarter Turn, Cast Copper Alloy Chromium Platedall As Specified And Directed. 2 S&F 15Mm Bore Health Faucets Fancy Type Chromium Plated Abs Body With 1 Meter Ss Braided Conection Pipe Complete All As Specified And Directed. 3 Internal Electric Supplys & F 15 Mm Bore Angular Stop Valve, Half Or Quarter Turn, Cast Copper Alloy Chromium Platedall As Specified And Directed. 4 Area Drainages&F Factory Made Steel Fibre Reinforcement Concrete ( Sfrc ) Cover Of Medium Duty 70-75Mm Thick With Perforated Holes 50Mm Dia And Set In Cm 1:6 Complete All As Specified. 5 Rain Water Harvasting Systemm&L For Drilling 250 Mm Dia Borehole By Dth Cum Rotary At Any Depth Below The Ground Level In Any Kind Of Rock / Soil Up To 40 M Depth Including Disposal Of Surplus Soil To A Distance Not Exe 50 Mtr Away All As Specified And Directed. 6 S&F Self Preforted Unplasticised Pvc Pipes 250 Mm Dia Of Pressure Rating 10 Kg / Sqcm Fixed Complete To Wall Or Ceiling Or In Floors Complete All As Specified. 7 External Water Supplysupply , Laying Jointing Testing Ductile Iron Pipe With Spigot Socketed Ends Class K-9 Conforming To Is 8329 With Inside Cement Mortar Lining Laid In Trenches Of100mm Bore Sizecomplete Includingjoints And Jointing Materials Suitable For Di Pipes All As Specified And Directed 8 Supply , Laying Jointing Testing Ductile Iron Pipe With Spigot Socketed Ends Class K-9 Conforming To Is 8329 With Inside Cement Mortar Lining Laid In Trenches Of80mm Bore Size All As Specified And Directed 9 External Electric Supplysupply Installation Testing And Commissioning Factory Made And Tested ( Incl Cpri Type Test Certified ) Lt Feeder Pillar Box ( Kiosk ) Outdoor Type Plateform Mounted Suitable For 415 Volts 3 Phase 4 Wire 50 Hzs Ac Supply System Having Bus Bar Chamber With Insulated Aluminium Bus Bar 500 Amps Rating Installed On Porcelain Insulators. The Panel Shall Be Dust And Virmin Proof Ip 65Protection And Made Of 3.15Mm Crcams Sheet And 40X40x6 Mm Thick Angle Iron Frame Work, Powder Coated Finish Over One Coat Of Red Oxide Primer Outside And Two Coats Of Red Oxide Primer Inside, Front Opening Type With Provisions For Cable Entry With Double Door Shutter And Locking Arrangement Including Provision Of 65Mm Godrej Freedom Lock With 2 Keys, Internal Wiring With Pvc Insulated Solid Copper Conductor Frls Cable Is 694 Marked Of Adequate Size But Not Less Than 4 Sqmm. The Shouild Be Suitable For Housing In And Including The Following :- 10 ( A ) Incoming : 11 ( I ) Mccb 4 Pole 320 Amps 50 Ka Rating Capacity - 01 No 12 ( Ii ) Volt Meter 0-500 Volts Flush Patern With Selector Switch - 01 Set 13 ( Iii ) Ammeter Flush Patern Having Range 0- 1000 Amps With Selector Switch - 01 Set 14 ( Iv ) Cts With Ratio 400 / 5 Class Isi Marked- 01 Set Of Three 15 ( V ) Led Type Indicating Lamp ( R.Y.B ) - 01 Set Of Three 16 ( B ) Outgoing 17 ( I ) Mccb 4 Pole 415 Volts 250 Amps Rating And Repturing Cap 35 Ka - 02 No ( Incl 1 Spare ) 18 ( J ) Mccb 4 Pole 415 Volts 63 Amps Rating And Repturing Cap 25 Ka - 02 No ( Incl 1 Spare ) 19 ( K ) Mcb Dp 32Amps With Astronomical Timer And 32 A Contactor Etc Complete For Street Light-01 Set 20 Supply Installation Testing And Commissioning Factory Made And Tested ( Incl Cpri Type Test Certified ) Lt Feeder Pillar Box ( Kiosk ) Indoor Type Plateform Mounted Suitable For 415 Volts 3 Phase 4 Wire 50 Hzs Ac Supply System Having Bus Bar Chamber With Insulated Aluminium Bus Bar 600 Amps Rating Installed On Porcelain Insulators. The Panel Shall Be Dust And Virmin Proof Ip 65Protection And Made Of 2 Mm Crcams Sheet And 40X40x6 Mm Thick Angle Iron Frame Work, Powder Coated Finish Over One Coat Of Red Oxide Primer Outside And Two Coats Of Red Oxide Primer Inside, Front Opening Type With Provisions For Cable Entry With Double Door Shutter And Locking Arrangement Including Provision Of 65Mm Godrej Freedom Lock With 2 Keys, Internal Wiring With Pvc Insulated Solid Copper Conductor Frls Cable Is 694 Marked Of Adequate Size But Not Less Than 4 Sqmm. The Shouild Be Suitable For Housing In And Including The Following :- 21 ( A ) Incoming : 22 ( I ) Mccb 4 Pole 400 Amps 50 Ka Rating Capacity - 01 No 23 ( Ii ) Volt Meter 0-500 Volts Flush Patern With Selector Switch - 01 Set 24 ( Iii ) Ammeter Flush Patern Having Range 0- 1000 Amps With Selector Switch - 01 Set 25 ( Iv ) Cts With Ratio 400 / 5 Class Isi Marked- 01 Set Of Three 26 ( V ) Led Type Indicating Lamp ( R.Y.B ) - 01 Set Of Three 27 ( B ) Outgoing 28 ( I ) Mccb 4 Pole 415 Volts 320 Amps Rating And Repturing Cap 50 Ka - 02 No ( Incl One Spare ) 29 S&F Led Street Light Fitting 1X45 Watt Ip-65 Complete With Fixing Bracket Of Suitable Size Gi Pipe Light Grade Not Less Than 1 Mtr Length, Connection Wire From Pole Box To Light Fitting Of 2X1.5 Sqmm And 1 X 1.5 Sqmm As Earth Wire In Steel Conduit As Required Complete In All Respect As Directed. 30 Boring Of Holes Under Road, Pavement, Hard Standing By Trenchless Technology Using Ultra Sounding Technique And Necessary Machine Including Hdpe Pipe Of 150 Mm Dia Suitable For 0.4 Mpa Working Pressure. 31 Fire Fighting & Fire Alarm Systemsupplying, Erecting &Commissioningfollowing Fire Cabinet:- 32 A ) Supplying And Fixing Single Headed Internal Hydrant Valve With Instantaneous Gun Metal / Ss Coupling Of 63 Mm Dia With Cast Iron Wheel, Isi Marked, Conforming To Is 5290 ( Type A ) With Blank Gunmetal Cap And Chain As Required. 33 B ) Providing And Installation Of 63 Mm Dia, 2 X15 Mtr Long Rubber Lined Woven Jacketed Hose Pipe, Type- A ( Reinforced Rubber Lined ) Of Is636-1988 Complete With Necessary Instantaneous Spring Lock Type Coupling At The Ends To Match With Landing Valve / Hose Pipe / Branch Pipe With Gunmetal / Ss Male & Female Couplings ( Is:903:1993 ) ( Make : Padmini / Omex / Torrent ) 34 C ) 1No Gun Metal Branch Pipe With Nozzle ( 63Mmx20mm ) With Gun Metal Gate / Ball Valve ( 20Mm ) 35 D ) Two Keys In Recess Type Compartment For Break Glass 36 E ) Supplying And Fixing First-Aid Hose Reel With Ms Construction Spray Painted In Post Office Red Drum And Brackets, Conforming To Is 884 With Upto Date Amendments, Complete With The Following As Required. ( A ) 30 M. Long 20 Mm ( Nominal Internal ) Dia Water Hose Thermoplastic ( Textile Reinforced ) Type-2 As Per Is: 12585 ( B ) Drum And Brackets For Fixing The Equipments On Wall, Connections From Riser With 25 Mm Dia Stop Valve & M.S. Pipe ( C ) Branch Pipe With Nozzle Of 20 Mm For Hose Reel Conforming To Is-8090 37 F ) The Double Door With Frame Of Size 1000Mm X 1650Mmmade Of 18 Gauge , 4Mm Inside Glass Painted Red. 38 Dg Setsupply, Installing, Commissioning And Testing Complete Of Manufacturer Or Oem ( Original Eqpt Manufacturer ) Manufactured And Tested Static Diesel Engine Driven Generating Set Capable Of Delivering 40 Kva ( 32 Kw ) , Or Nearest Higher Rating 415 Volts ( Ac 3 Phase, 4 Wire System Of Supply ) , 50 Hz To Operate At A Powers Factor Of 0.8. The Dg Set Shall Consist Of A Diesel Engine Coupled Through Flexible Coupling To A Matching Alternator And Mounted Onavm Pads ( As Per Respective Mnufacturer Design ) On A Common Base Frame All As Specified Complete With Control Panel Standardised By Manufacturer, Fuel Tank With Mounting Arrangement And Inlet, Outlet, Return Oil Arrangement, Flexible Exhaust Pipe Complete And Shall Comprise Of The Following: - 39 ( A ) Engine ( Prime Mover ) :Diesel Engine 1500 Rpm Of Suitable Hp As Recommended By Manufacturer But Not Less Than 43 Bhp ( At Ntp ) Water Cooled, Turbocharged Aircooled, 1 X90 Ah 12 Volts Electric Battery Start, Confirming To Bs 5514, Bs 649 And Is 10000 Complete With Fly Wheel And All Standard Fittings / Fixtures As Per Manufacturing Practice Including Suitable Engine Control Panel With Tachometer, Lub Oil Temp & Pressure Gauges, Water Temp Gauge, And Frequency Meter ( Digital Type ) ( Including Safety Shutdown Contents ) And Also Including Self Starter, Dynamo, Fuel Tank Etc. 40 ( B ) Alternator : Ac Alternator, Self Excited, Self Regulated, Self Ventilated, Brushless Design, Conforming To Bs 2613 / 5000, 3 Phase , 415 Volts, 4 Wire Rated Line Current45 Amps For Outputpf 0.8, 1500 Rpm, Insulation Class ‘H’ Temprature Reise H @ 40 Deg C; Enclosure Ip 23Confirming To Is-4722 / Bs-2613 Complete With Avr With + 1 % Voltage Regulation, Directly Coupled To And Match The Above Engine. 41 ( C ) Anti-Vibration Pads For Mounting Engine – Alternator Assembly On The Base Frame / Plate. 42 ( D ) Base Frame:One No. Ms Fabricated Adequately Machine Channel Common Base Frame With Lifting Facility, Pre-Drilled Foundation Holes Suitable For Permanent Installation On Concrete Foundation For Direct Grouting Or On Anti-Vibration Mountings Which Will Be Suitable To Receive The Offered Engine And Alternator Duly Coupled Through A Flexible Coupling. A Suitable Coupling Guard Shall Also Be Provided 43 ( E ) Silencer: Critical Gradeand Exhaust Gas Piping System Of Suitable Dia Ms Pipe Of B Class Of Required Legth As Per Cpcb Norms With Necessary Bends, Supports And Clamps Anti Vibration Mounting Inulated With Rockwool50 Mm Thick With Wire Mesh And Aluminium Clading Complete All As Specified 44 ( F ) Fuel Tank Of 100 Litres / Specified By The Manufacturer, Made Of 14 Swg Crca Ms Sheet, Duly Powder Coated And Provided With Float, Gauge And Fuel Float Switch. 45 Amf Panel:- 46 Fabricating, Installing, Testing & Commissioning Of Automatic Mains Failure Control Including Auto By-Pass Panel, Suitable For 40 Kva Silent Type Dg Set Complete With Relays, Timers, Set Of Cts For Metering & Protection And Energy Analyzer To Indicate Currents, Phase And Line Voltages, Frequency, Power Factor, Kwh, Kvarhprovision For Overload, Short Circuit, Restricted Earth Fault, Under Frequency, Control Cabling From Amf Panel To Diesel Engine And Elsewhere If Required, All Complete And Inter Locking Including For Following: 47 Mccb 63 Amps. 4 Pole 48 Auto / Manual / Test / Off Selector Switch 49 ( A ) 2 Nos Over Voltage Relay, 2 Nos Reverse Power Relay And 2 Nos Under Voltage Relay. 50 ( B ) 3 Sets Of Current Transformers 15 P 10 Accuracy For Protection And 15 Va Class-I For Metering 51 ( C ) Energy Analyzer Unit To Indicate Current Voltage Frequency Power Factor And Kwh 52 ( D ) Indicating Lamps For Load On Mains And Load On Set 53 ( E ) Fuse For Instruments 54 ( F ) Battery Charger, Complete With Transformer / Rectifier, D.C Voltmeter And Ammeter, Selector Switch For Trickle, Off And Boost And Current Adjustment 55 ( G ) Main Supply Failure Monitor 56 ( H ) Supply Failure Timer 57 ( I ) Restoration Timer 58 ( J ) Control Unit With Three Impulse Automatic Engine Start / Stop And Failure To Starty Lockout 59 ( L ) Impulse Counter With Locking And Reset Facility 60 ( I ) Audio / Video Annunciation For 61 ( Ii ) High Water Temperature 62 ( Iii ) Low Lubricating Oil Pressure 63 ( Iv ) Engine Over Speed 64 ( V ) Engine Fails To Start 65 ( Vi ) Full Load / Maximum Load Warming 66 Liftsupply, Installation, Erecting , Testing And Commissioning By Oem Of Passenger Elevator Electrically Operated Of Capacity 8 Passenger ( 544 Kg ) Gearless Machine ( Machine Room Less ) And Including Fixing Arrangement With Microprocessor Controller ( Vvvf ) Based ( Including Drive Calibration Pad For Upload / Down Load The Data ) , Selective Collective Control, Speed 1.5 M Per Second Serving Ground Floor And Five Upper Floor ( G+10 ) , Total Eleven Landings, Infra Red Screen Door Sensor, Over Load Warning Indicator, Intercom System With Single Automatic Push Button Operation With / Without Attendant, Having Suitable Car / Case Size, Automatic Centre Opening Doors ( Car & Landing ) In Ss Hair Line Finish, Stainless Steel Hand Rails ( Od>40Mm ) On 3 Sides Of Car Cabin, Floor Annunciator With Music / Arrival Chime, Car Operating Panel Both Sides, Emergency Battery Backup For Light, Car Cabin Made Out Of Minimum 18 Swg Stainless Steel ( Hairline Finsh ) As Well As Car Cabin Roof Covered With 18 Swg Stainless Steel ( Hair Line Finish ) , Cabin Floor Made Of Black Polish Granite Stone Of Minimum 13Mm Thick And As Per Is Specifications Complete Having A Minimum Fire Resistance Rating Of 02 Hours Complete All As Specifed And Directed 67 ( A ) Led Light Ultra Slim Decorative Aluminium Casted, Recess Mounted Square Fixture In White With Opal Diffuser And Separate Electronic Driver, Suitable For Low Depth Ceiling -12W Blaze Square With Complete Accessories Including Necessary Wiring - 04 Nos.Make:- Havells ( Cat Part No. Lhebmfp6iz2w012 ) Or Equivalent Model In Cg / Philips. 68 ( B ) Single Phase Centrifugal Type Cross Flow Blower 270 Cu Meter / Hour-02 Nos. 69 ( C ) Electrically Operated With Electric Motor Ac 415 Volts, 3 Phase 50 Hz Of Suitable Capacity As Per As Per Is ( Minimum Efficiency Class Equivalent To Ie 2 And Operating Gearless Box With Independentmain Sheave Rim. 70 ( D ) Electric Cabling And Wiring In Frls Copper Cable Including All Necessary Pvc Conduits Isi Marked Of Suitable Size 71 ( E ) Micro Processor Based Vvvf Type Main Controller With Closed Loop System. 72 ( F ) Type Of Signal System Figs Fixtures With Dot Matrix Display And Car Position Indicator In Car All Fixture In Ss Face Plate ( Bothinsided / Out-Side ) .All Buttons Should Be With Brail Marking And Luminous. 73 ( G ) Provn Of Travelling Cable With Copper Conductor Frls Of Suitable Size & Core Or Required Wiring To Intercom Speaking, Connect To Complete Cell And Provn Of Through & Other Accessories. 74 ( H ) Iinbuilt Ard ( Automatic Rescue Device ) With Maintenance Free Batteries Operated To Bring The Car Cage To The Nearest Floor Level In Case Of Power Failure, Which Includes Power Failure Of One Or More Phase. Emergency Light And At Least One Fan Inside The Lift Car Shall Be Operational Till The Rescue Operation And An Audio And Visual Indicator Shall Be Provided Inside The Lift Car To Alert The Persons Trapped Inside They Are Being Rescued. 75 ( J ) Provision Of Governor Grooved Belt And Along With Belt Monitoring Device Which Can Ensure To Prevent From Any Breakage Of Belt And Taking Elevator To Nearest Landing Of Suitable Size, Buffer Springs As Per ManufactureS Design, Car Cabin Having Powered Doors And Inspection Box At Top Of The Car Cabin, Compact High Efficiency Drive Combined With Suspension Traction Media Technology. 76 ( K ) Provision Of Safety Guarding Equipments Such As 02 Nos Pit Switches Controller, Guarding Pit, Pulley, Guarding Pit Ladders, Facia Plate Tocoverfree Space Between Car Cabin And Hoist Way & Switches. 77 ( L ) Door Sensor Not Less Than 74 Beam, 2D Infra Red Full Length. 78 ( M ) Provision Of Fire Man Switch Complete At Ground Floor Fitted In Box Including Ss Face Plate. 79 ( N ) Provision Of Press And Speak System To Be Connected With Lift Complaint Cell Compatible With Exchange. Provision Of Automatic Call Registration In Case Of Breakdown 80 ( O ) DoS & Don’Ts Chart On Stainless Steel To Be Installed Inside The Car Cabin. 81 ( P ) A Three Pin Plug Socket With Switch For Hand Lamp Shall Be Fitted Top Of The Lift Car For Use By Person Working There On. 82 Supply, Installation, Erecting , Testing And Commissioning By Oem Of Passenger Elevator Electrically Operated Of Capacity13 Passenger ( 884 Kg ) Gearless Machine ( Machine Room Less ) And Including Fixing Arrangement With Microprocessor Controller ( Vvvf ) Based ( Including Drive Calibration Pad For Upload / Down Load The Data ) , Selective Collective Control, Speed 1.5 M Per Second Serving Ground Floor And Five Upper Floor ( G+10 ) , Total Eleven Landings, Infra Red Screen Door Sensor, Over Load Warning Indicator, Intercom System With Single Automatic Push Button Operation With / Without Attendant, Having Suitable Car / Case Size, Automatic Centre Opening Doors ( Car & Landing ) In Ss Hair Line Finish, Stainless Steel Hand Rails ( Od>40Mm ) On 3 Sides Of Car Cabin, Floor Annunciator With Music / Arrival Chime, Car Operating Panel Both Sides, Emergency Battery Backup For Light, Car Cabin Made Out Of Minimum 18 Swg Stainless Steel ( Hairline Finsh ) As Well As Car Cabin Roof Covered With 18 Swg Stainless Steel ( Hair Line Finish ) , Cabin Floor Made Of Black Polish Granite Stone Of Minimum 13Mm Thick And As Per Is Specifications Complete Having A Minimum Fire Resistance Rating Of 02 Hours Complete All As Specifed And Directed By Engineer-In-Charge. 83 ( A ) Led Light Ultra Slim Decorative Aluminium Casted, Recess Mounted Square Fixture In White With Opal Diffuser And Separate Electronic Driver, Suitable For Low Depth Ceiling -12W Blaze Square With Complete Accessories Including Necessary Wiring - 04 Nos.Make:- Havells ( Cat Part No. Lhebmfp6iz2w012 ) Or Equivalent Model In Cg / Philips. 84 ( B ) Single Phase Centrifugal Type Cross Flow Blower 270 Cu Meter / Hour-02 Nos. 85 ( C ) Electrically Operated With Electric Motor Ac 415 Volts, 3 Phase 50 Hz Of Suitable Capacity As Per As Per Is ( Minimum Efficiency Class Equivalent To Ie 2 And Operating Gearless Box With Independentmain Sheave Rim. 86 ( D ) Electric Cabling And Wiring In Frls Copper Cable Including All Necessary Pvc Conduits Isi Marked Of Suitable Size 87 ( E ) Micro Processor Based Vvvf Type Main Controller With Closed Loop System. 88 ( F ) Type Of Signal System Figs Fixtures With Dot Matrix Display And Car Position Indicator In Car All Fixture In Ss Face Plate ( Bothinsided / Out-Side ) .All Buttons Should Be With Brail Marking And Luminous. 89 ( G ) Provn Of Travelling Cable With Copper Conductor Frls Of Suitable Size & Core Or Required Wiring To Intercom Speaking, Connect To Complete Cell And Provn Of Through & Other Accessories. 90 ( H ) Iinbuilt Ard ( Automatic Rescue Device ) With Maintenance Free Batteries Operated To Bring The Car Cage To The Nearest Floor Level In Case Of Power Failure, Which Includes Power Failure Of One Or More Phase. Emergency Light And At Least One Fan Inside The Lift Car Shall Be Operational Till The Rescue Operation And An Audio And Visual Indicator Shall Be Provided Inside The Lift Car To Alert The Persons Trapped Inside They Are Being Rescued. 91 ( J ) Provision Of Governor Grooved Belt And Along With Belt Monitoring Device Which Can Ensure To Prevent From Any Breakage Of Belt And Taking Elevator To Nearest Landing Of Suitable Size, Buffer Springs As Per ManufactureS Design, Car Cabin Having Powered Doors And Inspection Box At Top Of The Car Cabin, Compact High Efficiency Drive Combined With Suspension Traction Media Technology. 92 ( K ) Provision Of Safety Guarding Equipments Such As 02 Nos Pit Switches Controller, Guarding Pit, Pulley, Guarding Pit Ladders, Facia Plate Tocoverfree Space Between Car Cabin And Hoist Way & Switches. 93 ( L ) Door Sensor Not Less Than 74 Beam, 2D Infra Red Full Length. 94 ( M ) Provision Of Fire Man Switch Complete At Ground Floor Fitted In Box Including Ss Face Plate. 95 ( N ) Provision Of Press And Speak System To Be Connected With Lift Complaint Cell Compatible With Exchange. Provision Of Automatic Call Registration In Case Of Breakdown 96 ( O ) DoS & Don’Ts Chart On Stainless Steel To Be Installed Inside The Car Cabin. 97 ( P ) A Three Pin Plug Socket With Switch For Hand Lamp Shall Be Fitted Top Of The Lift Car For Use By Person Working There On. 98 Aviation Lights & F Aviation Obstruction Light ( Twin ) Aviation Yellow Painted Die Cast Al Alloy Housing, Red Coloured Polycarbonate Dome And Accessories Suitable For Led 2X6 Watt Complete All As Specified And Directed.
