Supply Installation Testing And Commissioning Of Substation Equipments, Swithchgears At New Electrical Substion At General Hospital Morbi.-Providing, And Erecting 11 Kv D.P. 9 Mtr. High Structure Made Of 6 X 3 ‘I’-Section Girder, 4 X 2Channels, Clamps, Nuts, Bolts Etc. Suitable For Erection Of The Followings Duly Connected With Necessary Acsr Conductors. As Per Drawing Approved By The Engineer- In Charge Complete With Following. Height As Per Is 7 Mtr Above Ground ) ( A ) 11 Kv 200 Amps Drop Out Fuses With S.R.B.P. Tubes Carries.-Three Nos ( B ) 11 Kv G.O.D. Switch Complete With Insulators, Operating Handle With Galvanised Pipe, Sq.Bar Etc. 400 Amp.- One Set ( C ) 11 Kv Lightening Arrestor With Clamp- Three Nos. ( D ) 11 Kv Shackle Insulators- Six Nos. ( E ) The Above D.P. Structure Should Be Earthed With 25 Mm.X 3 Mm Thick Double Copper Earth Strips Run Separately And Connected With Separate Copper Plate Earth Electrode , Providing, Erecting, Testing Commissioning & Getting Plan Approval As Well As Noc From Electrical Inspector For Extensible H.T Panel Comprising Of One 400A. H.T. Vcb Incoming & Two Outgoing 400 A Drawout Type Vcb Confirming As Per I.S. For Use On 11 Kv, 3 Phase, 50 C / S. Unearthed A.C. Supply System , 10. Cable Boxes Suitable Up To 11 Kv 3Core 150 Sq.Mm Xlpe Cable, Providing, Erecting, Testing & Commissioning Approved Make Oil Immersed Onan Cooled, Double Wound, Core Type Indoor / Outdoor Copper Wound 11Kv / 433V Step Down Transformer Of Following Capacities Operating On 3 Phase, 50 Hz 4 Wire & Neutral Earthed System Continuously Rated For A Full Temperature Rise In Oil Not Exceeding 45 Deg.C.At Maximum Ambient Temp. Of 50 Deg. C. Complete With Necessary Radiator First Filling Of New Transformer Oil & Standard Fitting As Below Complying With Is 1180 ( Part 1 ) :2014 Standards With Energy Efficiency Level 2 , 11. Earthing Terminals - Two Nos. 12. Lifting Lugs - Two Nos. 13. Air Release Plug. - One No. 14. Double Float Buchholz Relay With Alarm And Trip Contacts. 15. Control Cable As Required From Transformer To Vcb Panel Is To Be Provided With Necessary Connection To Vcb Relays For Protection. As Per Is 1180 Level-2 , Providing, Erecting, Testing Commissioning & Getting Plan Approval , If Required Noc From Electrical Inspector For Extensible L.T. Panel With Required All Internal Connection I.E. Switch To Switch , Switch To Busbar, Switch To Other Etc. , Design, Supplying, Installing, Testing Of Factory Fabricated Ready Made Three Phase Apfc Panel Cubical Panel Fabrication Should Be Type Tested As Per Iec 61921, 61439:1&2 Capacitor Duty Contactor For Switching , 0 00-01-00 ( F ) 200Kvar ( 50Kvar X 2 Nos And 25Kvar X 3, 10Kvar X 2Nos, 5Kvar X 1 Nos. Steps ) ( Make-Abb, Subodhan, Siemens, Schneider ) 6 4-3-3. Providing And Erecting Xlpe ( Is:7098 ) ( I ) -88 Isi Armoured Cable Multistrand Aluminium Conductor For 1.1 Kv. To Be Laid On Wall With Necessary Clamps Or In Existing Trench / Pipe Of Following Size Of Cables 0 00-01-00 ( J ) 3 1 / 2 Core 400 Sq.Mm ( 185 Sq. Mm 1 / 2 Core ) 0 00-01-00 ( G ) 3 1 / 2 Core 185 Sq. Mm ( 95 Sq. Mm 1 / 2 Core ) 0 00-01-00 ( H ) 3 1 / 2 Core 240 Sq. Mm ( 120 Sq. Mm 1 / 2 Core ) 7 4-6-3. Providing And, Fixing Heavy Duty Flange Type Brass Double Compression Type Cable Gland With Rubber Ring For Pvc Insulated Armoured Cable Complete With Out Going Tails, Insulating Tape Etc For Following Size Of Cables. 0 00-01-00 ( J ) 3 & 1 / 2 Core 400 Sq. Mm 0 00-01-00 ( G ) 3 & 1 / 2 Core 185 Sq. Mm 0 00-01-00 ( H ) 3 & 1 / 2 Core 240 Sq. Mm 8 4-7-1. Solder Less Crimping Type Aluminium Lugs Conforming To Is Suitable For Cable Of Following Size Evenly Crimped With High Pressure Tool & Connected To Switchgear Terminals With Brass / Cadmium Plated Nut Bolts In An Approved Manner. 0 00-01-00 ( L ) 400 Sq.Mm. 0 00-01-00 ( I ) 185 Sq.Mm. 0 00-01-00 ( J ) 225 Sq.Mm. 9 .4-11-1 Providing And Fixing Approved Make Perforated C Type Cable Tray. Made From Sheet Steel. The Cable Tray Should Be Single Or Double Bended As Per Required And As Per Is 2062 / 1079 And Shall Be Coated With Hot Dip Galvanizing As Per Is 2629 / 4759. With Max 17.5% Perforation With Coupler Plate / Fish Plate And Gi Hardware Like Nut - Bolt And Washers Etc. Erection With Necessary Support ( Included ) As Per Specification And As Per Instruction Of Engineer In Charge.. 0 00-01-00 ( 8 ) 750 X 50 X 2.0 Mm Thick 10 .4-11-3 Providing And Fixing Approved Make 90° Elbow For Perforated C Type Cable Tray. Made From Sheet Steel. The Junction Should Be Bended As Per Is 2062 / 1079 And Shall Be Coated With Hot Dip Galvanizing As Per Is 2629 / 4759. With Coupler Plate / Fish Plate And Gi Hardware Like Nut - Bolt And Washers Etc. Erected On Existing Support As Per Specification And As Per Instruction Of Engineer In Charge.. 0 00-01-00 ( 8 ) 750 X 50 X 2.0 Mm Thick 90° Elbow 11 4-11-4. Providing And Fixing Approved Make Cross Over Junction For Perforated C Type Cable Tray. Made From Sheet Steel. The Junction Should Be Bended As Per Is 2062 / 1079 And Shall Be Coated With Hot Dip Galvanizing As Per Is 2629 / 4759. With Max 17.5% Perforation With Coupler Plate / Fish Plate And Gi Hardware Like Nut - Bolt And Washers Etc. Erected On Existing Support As Per Specification And As Per Instruction Of Engineer In Charge.. 0 00-01-00 750 X 50 X 2.0 Mm Thick Cross Junction 12 10-2-15 Providing And Erecting Isi Marked 3Core 150 Sq.Mm Xlpe Insulated 11 Kv Armoured Cable Aluminium Conductor Is-7098 To Be Laid On Wall With Clamps Or In Provided Cable Trench / Pipe Approved Manner As Directed. 13 10-2-17 Providing And Erecting Cable End Termination Kit, Heat Shrinkable Push On Type Densons’ / ‘Raychem’ / Elastimold Make Suitable For 11 Kv Xlpe Cable 3 Core 50 & 70 Sq.Mm 0 00-01-00 ( A ) Outdoor Type 0 00-01-00 ( B ) Indoor Type 14 10-2-2. Providing Pair Of Rubber Hand Gloves Suitable For Working On 11 Kv / 22 Kv Supply. 15 10-2-3 Supplying Rubber Matting Of Following Thickness As Per Is:15652 / Iec 61111 ( B ) 4Mm 16 10-2-5 Supplying Fire Bucket Round Bottom Of 9 Litres Capacity Made Out Of 24 Gauge G.I. Sheet With Extra Handle At Bottom Duly Painted White Inside And Red Out Side With Fire Mark, Filled With Dry-Sand And Kept On Stand Provided . 17 10-2-4 Supplying Stand First Aid Box With Antiseptic Cream, Medicine For Use On Wounds Due Burn, Crepe Bandage, Gauge Bandage, Medicated Ready To Use Bandage ( Band-Aid ) Adhesive Tape For Medicinal User, Scissors, Anti-Septic Solution ( Savlon Or Similar ) Etc. ( All Above Contents Shall Be Of Standard Makes ) 18 10-2-23 Supplying & Erecting D.C.P. Type Fire Extinguisher For Following Capacity Cartridge Type With Gun Metal Cap 150 Gram Co2 Gas Cartridge, Powder And Brackets Confirming To Is 2171 1985 And Complete Erected With Necessary Clamps Made From 50 X 6 Mm M S Flat With Nuts And Bolts Grouted In Wall Complete. [ A ] For 5 Kg Capacity 19 10-2-24 Supplying & Erecting Carbon Dioxide ( Co2 ) Fire Extinguisher User Of Following Capacity With Necessary Clamps Made From 50 X 6 Mm M.S. Flat With Nut & Bolts Grouted In Wall Complete. [ A ] For 4.5 Kg Capacity 20 3-14-3 Providing And Erecting Required Size Copper Strip For Earthing Of H.T. Ocb / Acb / Transformer, Lt Panel Board, Motors Etc. Using Copper Clamp. 21 10-3-37. Supplying & Fixing Steel Chequered Plate Having 7 Mm Thickness, Duly Painted With Two Coats Of Black Japan Colour. ( Average Wt 61.1 Kg / Sq.Mtr ) 22 1-2-1. Point Wiring For Light / Bell With 2-1.5 Sq.Mm & Earth Wire Of 1.5 Sq.Mm ( Green ) Both Are Of Isi Marked 1.1 Kv Grade Frls Pvc Insulated Multi Strand Copper Wires Up To 10 Mtr Length , In Below Type Of Pipe Erected With 6A Modular Type Switch / Bell Push & Accessories And Earth Continuity Of Following Type, Erected On Pvc / Metallic / Wooden Box, Single Mounting Base Frame Covered With Textured / Metallic / White Front Plate Modules Erected On / In Wall / Ceiling As Per Pipe Erected, With Necessary Lamp Holder / Ceiling Rose / H.D.Connector As Directed. ( A ) With Medium Class Rigid Pvc Pipe And Accessories Erected Flushed On Wall / Ceiling Complete Cat. Ii 23 1-2-2. Point Wiring For Fan With 2-1.5 Sq.Mm & Earth Wire Of 1.5 Sq.Mm ( Green ) Both Are Of .Isi Marked 1.1 Kv Grade Frls Pvc Insulated Multi Strand Copper Wires Up To 10 Mtr Length, In Below Type Of Pipe Erected With 6A Modular Type Switch And Hum Free Eme Four Or More Step Type Electronic Fan Regulator With Separately Mounted And Accessories With Earth Continuity Of Following Type Erected On Pvc / Metallic / Wooden Box, Single Mounting Base Frame Covered With Textured / Metallic / White Front Plate Modules Erected On / In Wall / Ceiling As Per Pipe Erected. With Necessary Ceiling Rose / H.D.Connector As Directed. ( A ) With Medium Class Rigid Pvc Pipe And Accessories Erected Flushed On Wall / Ceiling Complete Cat. Ii 24 1-2-3. Point Wiring For Individual Plug With & Earth Wire Of 1.5 Sq.Mm ( Green ) Both Are Of Isi Marked 1.1 Kv Grade Frls Pvc Insulated Multi Strand Copper Wires Up To 10 Mtr Length, In Below Type Of Pipe Erected Complete With Modular Type Switch & 5 Pin Plug Erected On Pvc / Metallic / Wooden Box Covered With Appropriate Front Plate Modules Erected On / In Wall / Ceiling As Per Pipe Erected With Following Type Of Accessories. [ Ii ] For 16A Plug And 16 Amp Switch With 2-2.5 Sq.Mm Cu. Wire From Mcb Db Board. ( A ) With Medium Class Rigid Pvc Pipe And Accessories Erected Flushed On Wall / Ceiling Complete Cat. Ii 25 1-2-4. Point Wiring For On Board Looped Plug With 6A Modular Type Switch & 5 Pin Socket Erected On Pvc / Metallic / Wooden Box, Single Mounting Base Frame Covered With Textured / Metallic / White Front Plate Modules Erected On / In Wall / Ceiling With Following Type Accessories Cat. Ii 26 1-3-2. Providing And Erecting Isi Mark Medium Class Rigid Pvc Pipes Of Following Size Complete To Be Erected On / In Wall Or Ceiling Erected With Necessary Pvc Fittings & Junction Boxes Fixed With Adhesive Solution & Clamps With Following Dia Of Pipes, In Approved Manner As Directed ( A ) 20 Mm 27 1-4-1. Providing And Erecting Mains With 1.1 Kv Grade Frls Pvc Insulated Isi Marked Stranded Copper Conductor Wire In Following Type Of Pipe To Be Erected Concealed In / Flushed On Wall / Ceiling, With 1.5 Sq. Mm Copper Conductor Frls Pvc Insulated Stranded Wire Of Green Colour For Earth Continuity Of Following Size ( A ) With Medium Class Rigid Pvc Pipe And Accessories ( B ) 2 Wire 2.5 Sq. Mm 28 3-11-5. Providing And Erecting Sheet Steel Powder Coated Mcb Distribution Board - Flush / Surface Mounted Fitted With Busbar, Neutral Link, Earth Bar And Din Rail, Conforms To Is 8623-1 & 3, Iec 61439-1 & 3 Without Mcb To House Appropriate Nos. Of Mcbs. ( The Dbs Should Be Used Of Same Company Of Mcb To Be Used ) Suitable For 0 00-01-00 ( B ) Three Phase Incoming And Single Phase Horizontal Type Outgoing Per Phase Isolation Type ( Ppi ) ( B ) Sheet Steel Double Door ( Ip-43 ) ( Ii ) 6 Way 29 3-10-1. ( B ) Providing And Erecting Miniature Circuit Breaker Single Pole 6A To 25A Suitable To Operate On 240 V A.C. System And Having Breaking Capacity 10 Ka To Be Erected In Existing Box. Confirming To Is 8828 / 1996 With Isi Mark Cat.Ii 30 3-12-3 Supplying & Erecting Approved Make Rccb + Mcb ( Electro Magnetic Type Only ) Working On Residual Current Device Having 10 Ka Short Circuit Breaking Capacity And 30 Mamp. Sensitivity & 30 Mili Sec. Tripping Time Conforming To Is 12640 Test Knob Facility Trip Free Mechanism Operating For Rated Leakage At Nominal Ten Volt, Complete Erected Including All Materials Lugs Screws Etc. Completed. [ C ] 63 A, 2 Pole Single Phase Cat. Ii 31 2-15-3 Supplying And Erecting Led Indoor Fittings With Leds Of Wattage 0.2 Watt To 0.5 Watt Assembled On Single Mcpcb, With Housing Used As A Heat Sink Shall Be Made Of Thick Sheet Steel Conforming To Is: 513 / Crca / Aluminium Die Cast Powder Coated And High U.V. & Corrosion Resistance With Diffuser With Company Mark / Name 120 To 300 V, Power Factor More Than 0.9, Thd < 10 %, Cct 3000 K To 6500K, Luminaire Efficacy> 85 Lumens / Watt , Led Efficiency-110 Lumens / Watt Led Driver Efficiency > 85 % Cree / Osram / Philips Lumileds / Nichia / Seoul / Bridgelux Make Led Used For Luminaire. ( Fitting Required Lm-79 & Lm-80 Certificates ) ( Note: Below Description Have Shown Ranges Of Wattage Capacity Of Led Fittings.The Engineer Incharge May Select Any Wattage Capacity Between The Ranges Shown. ) ( C ) 16-20 Watts, Surge - 2Kv, Ip-20, 4 Feet Cat-Ll 32 5-1-1. Providing And Erecting Approved Make Ceiling Fan With Double Ball Bearing Isi Mark With Condenser A.C. 23Ov.50 C / S.1200 Mm. Sweep Complete, Canopy Erected On Existing Hook Or Clamp With Earthing. [ Make Shall Be Approved By Engineer In Charge ] 33 5-2-3. Supplying & Erecting Fan Hook Box Of 10 Mm M.S. Round Bar Bounded To The Rcc Bars Up To 50Mm Length Each Side And Pierced Through A 16 Gauge M.S. Box / Heavy Duty Pvc Box Complete Erected Concealed In Ceiling With Necessary Finishing. 34 5-3-4. Supplying & Erecting Single Phase Approved Make Industrial Exhaust Fan Suitable For Medium Duty Ring Mounted Low Noise Operation Suitable For Medium Duty Having Following Dia Size And Maximum Speed In Rpm [ A ] 305 Mm Dia 900 Rpm Cat.I 35 4-5-1. Making Trench In Soft Soil Of Suitable Width Of 90 Cm Deep For Laying Cable Or Locating The Fault All Over The Run And Back Filling The Same And Making The Surface As Normal Ground. 36 3-13-1. Providing And Erecting Metallic Vitrified Danger Notice Board As Per Language Suggested By Engineer Incharge For Medium / High Voltage Installation To Be Erected As Per Is-2551. 37 3-14-9 Supplying & Erecting Earth Pit Of Minimum Bore Dia.150Mm Size Approved Make Earthing Electrode Consisting Pipe-In-Pipe Technology As Per Is 3043-1987 Made Of Corrosion Free Hot Dipped G.I.Pipes Having Outer Pipe Dia Of 50Mm Having 80-200 Micron Galvanising, Inner Pipe Dia Of 25 Mm Having 200-250 Micron Galvanising, Connection Terminal Dia Of 12Mm With Constant Ohmic Value Surrounded By Highly Conductive Compound With High Charge Dissipation Suitable For Following Type Of Applications With Chamber And Heavy Duty Cover. ( Approved Make Oem Has To Submit Test Certificate ) & Having Back Filling Compound Of ( B ) Inner Chemical ( Ccm Compound ) - Resistivity:- 0.2 / Meter Testing As Per Iec 62561- 2017, Voltage Drop:- < 1 Volt At No Load & Dry Form, Sulphar Content:- <2% ( C ) Back Fill Compound :- Earthing Compound Should Be Capable To Retain Moisture For Long Time Necessary Test Report Must Be Submitted. 0 00-01-00 ( C ) For Electrical Installation Covering Transformer Neutrals, Lightning Arrester Earthing, A.C.Plant & Sensitive Computer System ( Like Automation, Scada ) I.E Independent Earthing In Normal Soil. Length Of Pipe : 3.00 Mtrs Back Filling Compound :2 Nos Bags Of 25 Kg. 38 Supplying And Erecting Led Street Light / Flood Light Fittings With High Power White Leds Wattage Of 1Watt And Above Assembled On Single Mcpcb, Efficiency More Than 130 Lm / W And Corrosion Free High Pressure Die Cast Aluminum Housing With Smooth Finish Powder Coated And Heat Sink Extruded Aluminium With Diffuser And Polycarbonate Optics / Lenses With Company Mark / Name Engraved Or Embossed 120 To 300 V, Power Factor More Than 0.95, Thd < 10 %, Cct 3000 K To 5700K, 39 6-7-5 Supplying & Erecting Power Contactor , Ac3 Duty For Time Switch Complete Erected As Per Direction Cat Iii [ D ] 4 Pole 440V 40 Amp. 40 6-7-2 Supplying & Erecting Approved Make Digital Time Switch Having Lithium Cell 6 Years Operative And Operate Battery Backup 1 Channel Day Clock With 14 Memory Programme, Suitable To Operate On 240V + 5%, 16A With, Floating Contacts Minimum Switching Setup Time 1 Minimum & Lcd Display. Also Comprised Permanent On / Off Switching. Programming Switches & Housed In Fire Proof Thermoplastic Enclosure & Transparent Cover Erected As Required With Necessary Connection Erected As Directed. 41 1-6-2 ( B ) Providing & Erecting Switch Board For Computer Or Electric Apparatus Consisting Of Following Modular Type Accessories Mounted With Pvc / Metallic Concealed / Open Box With Single Mounting Base Frame Covered With Textured / Metallic / White Front Plate, Modules Erected With Necessary Connections As Directed 1 No. 6A / 16A Universal Plug-Switch Combined. 3 Nos. 6A Switch 3 Nos. 6A 5 Pin Plug 0 00-01-00 For Modular Type Accessories 0 00-01-00 Cat. Ii
