Tenders Are Invited For Upgrade Of Three (3) Hand Pumps To Solarized Water

Tenders Are Invited For Upgrade Of Three (3) Hand Pumps To Solarized Water 1 Achuolok Village, Achuolok Boma Akop Payam 75Km From Tonj North Town Tbd Tbd 2 Athiengpuol Phcu, Athiengpuol Boma - Akop 65Km From Tonj North Town 8*205.20 29*421.98 3 Magok Village Maguen Boma Akop - 70Km From Tnj North Town Tbd Tbd 01 Mobilization: Allow For The Cost Of Transporting All Equipment, And Personnel To Site And Demobilisation At Completion Of Contract. 01 Job 02 Site Survey, Preparation And Set Ups. 01 Job 03 Allow For Overhauling Of The Existing Hand Pump, Thereafter, Carry Out Pump Testing 01 Job 04 Allow For Reinstalling Back Of The Hand Pump For Temporary Use Before The Submersible Pump Is Installed. 01 Job 05 Overhaul The Hand Pump, Thereafter, Install The Submersible Pump, Solar Hand Pump Cylinder Using 11/4 G.I.Pipes Riser Mains To Depth Of 60.0M (20 Pipes And Connecting Rods) 01 Job 06 Provide But 11/4 G.I.Pipes Complete With Connecting Rods 20 Pieces 07 Ditto But Special Hand Pump Water Tank Assembly With Dual Out Lets 01 Piece 08 Ditto But Special Solar Hand Pump Stainless Steel Cylinder. 01 Piece 09 Ditto But Head Assembly Indian Mk Ii 01 Piece Pumping Test 10 Mobilize, Pumping Test For Step Draw Down And Constant Discharge Test, Including Installation Removal Of 01 Job 3 Pumping Test Equipment And Water Level Observation, For Not Less Than 6 Hours, Ensure 80% Well Recovery Is Achieved At End Of The Exercise, The Pumping Test Aims At Establishing The Recharge Capacity Of The Well And The Dynamic Water Level, Crucial For Designing The Pump And Pumping Flow Rate. Solar And Pump Items 11 Supply And Install Solar Powered Submersible Pump (Grandfos). Of Capacity 1,400 Watt, Single Phase, Q= 3,500 Liters/Hours, H= Approx.120 Meters. Preferably: Sqf Series, Model Dp2 1813, Vdc 30- 300V, Vac 1X90-240 V Phase 1. 01 Set 12 Supply And Install 4Mm 2-3 Core Submersible Drop Cable, Complete With Water Proof Couplings. 80 Meters 13 Supply And Install 4Mm 2-3 Core Underground Cable, In A Pvc Conduit Provision For Crossing Roads. 20 Meters 14 Supply And Install Solar Panels (Preferably 100-120 Watt Panels) Corresponding To 1,400 Watt Pump Capacity. Solar Panels Of 200 Watts Of High Advantage. 14 No 15 Solar Control Panel (Cu 200), 1,400 Watts, Grandfos. 01 No Cable Splicing Kits And Insulation Tape(Cello) 01 No Tank Tower 16 Provide And Fabricate Metallic Stainless Steel Tank Stand: - Angle Bar 75Mmx75mmx 6Mm Thick Or 100Mmx100mmx4mmx 6M Long, 4 Thick Hollow Section Pipes In Tower Legs, 4No. - 50Mmx50mmx 6Mm Rsa Thick Hollow Section Pipe In Diagonal Ties, 16No. - H Steel Bar 14Mm, 02 No -50Mmx50mmx6mm Rsa In Horizontal Braces 12 No - 100Mmx100mm Hollow Section Pipes In Secondary Beams 10No - Steel Flat Sheet 1Mx2m, 02 No - 15Mm Dia. X 150Mm Long Stud Bolts, 16 No. - Base Plate 25Mm Thick, 04 No - Grade 20M R.C Concrete 1:2:4, 8.02M3 In Footings. - Steel Access Ladder, 01 No - Steel Cage, 01 No. 01 Set 17 Y-6 Iron Bar In Stirrups 18 - Y-12 Iron Bar 180 M 19 - 1X10 Timber In Form Work, 48M Steel Tank 12,000 Liters 20 Supply And Install In Place, Stainless Steel Tank 12,000 Liters, Complete With Floater Valve And Water Level Sensor, Well Painted. 01 Piece Plumbing Items 21 In-Let From Pump To Tank: Supply And Install 11/4 Or 1 G.I. Pipes With Anti60 Meter 5 Rust Proof Or ( Hdpe Pipes Could Be Used) 22 In-Let From Well Head: 11/4 Or 1 One-Way Valve Fitted Alongside The Gate Valve In The Spout Out-Let. 01 23 Out-Let Pipe From Tank: Supply And Install 2 G.I.Pipes From Tank Out-Let To Ground Level Or Hdpe Pipes 8 Meter 24 Wash-Out Pipe From Tank: Supply And Install 2 G.I.Pipes From Tank Side 100Mm-150Mm Above Tank Base Fitted Alongside The Gate Valve In The Spout Out-Let. 01 Meter 25 2 Hdpe Pipes In Main Lines, Complete With All Fittings And Joints ( As In The Drawings), Excavation And Back Filling Included. 600 Meter 26 1 Hdpe Pipes From 2 Main Line To 03 Water Collection Points (200 M To Each Point), Complete With Fittings And Joints, Well Connected Into The Water Collection Point, Excavation And Back Filling Included. 600 Meter 27 2 Water Meter Installed At Out Let From The Tank, But At Ground Level. Well Completed In A 400Mmx400mm Brick Work Manhole With A Lid. 01 Piece Water Collection Points( Public Stand Posts/Tape Stands) 26 -Grade 20M Concrete, 1:2:4 Plains In Plate Form- 9.0M3 (3M3 /Each Point) 200Mm Thick Solid Block Work In 1:4 Cement To Sand Mortar, 6.0M2 (2M2 /Each Point), Well Plastered And Finished Smooth In Cement Putty. 1 Brass Bib Cocks (Water Tapes) 10 Pull Cord Switch (For Two Water Collection Point). ¾ Brass Bib Cocks 6 05 No (For One Water Collection Point Near The Tank) 1 Hdpe Pipe 6.0M (2.0M/Each Tap Stand). 1 Gate Valve Complete In A 400Mmx400mm Brick Work Manhole Chamber With Lid 03(01 Gate Valve/Each Tap Stand). All Required Fittings And Joints Inclusive. 03 No 27 Provide And Allow For Extra 4 Pvc Pipes Extension Of Drainage Channel Crossing Road, Excavation And Back Filling Included. 18 Meters Fencing Work : 28 (A) Provide And Carry Out Fencing Around The Tank To Perimeter, 7Mx5m (24 Linear Meters). -21/2X21/2X2.5M Long Angled Iron Bars In Main Posts Including Strainer Posts, Well Welded 14 Pcs, Line Wire, 02 Roles. Chain Link Wires, 04 Roles. Razor Wires 04 Roles. Line Wires 01 Role. Cement 04 Bags, Sand 1.5M 3 , Aggregate 2.5M 3 . Metal Door Complete With Provision For Locking 01 Piece. 01 No 29 (B) Provide And Carry Out Fencing Around Water Collection Points (Tap Stands) To Perimeter, 5Mx4m (18 Linear Meters). -21/2X21/2X2.5M Long Angled Iron Bars In Main Posts Well Welded, 14 Pcs, Line Wire, 02 Roles. Chain Link Wires, 03 Roles. Line Wires 01 Role. Cement 03 Bags, Sand 1.0M 3 , Aggregate 2.0M 3 . Metal Door Complete With Provision For Locking 01 Piece. 03 No 30 Provide And Allow For Excavation Of 1.5M Diam. X 2.0M Deep Pit Soak Away Pit, Filled With Selected Filling Stones, 03 No 7 Well Covered With Plastic Sheet And Soil. 31 Lightings: Provide And Install A 60 Watt, 6,000 Lumens, Public Solar Lights, Integrated With A Solar Panel, Well Fixed On A 4 Inches Dia. G.I. Pipe 6.00M High, Razor Wire Will Be Rolled On The Foot Of The Pole To Provide Additional Protection. The Solar Light Is Expected To Have Night And Motion Sensors, Operate At 30% When At Idle Mode And 100% When Darkness And Motion Is Detected. Well Installed In Each Of The Water Collection Points. 03 No 32 Visibility: Provide And Fabricate, Signpost (A) Length 1.20M X Height 0.80M Fabricated Using 40Mmx40mm Rectangular Pipes In Main Frames, On 21/2 X 21/2 Stands Angled Bars For (Legs) At Least 1.80M From The Ground Level. Sign Post 04 No 33 Visibility: Provide And Fabricate, Sign Post Length 1.20M X Height 0.80M, Fabricated Using 40Mmx40mm Hollow Section Pipes In Frames. This Sign Post Does Not Have Legs, Hence Is Fixed Up On The Front Side Of The Tank. 01 No 8 34 Provision And Allow Proper Fixing In Place Of Anti-Thunder Arrest System 01 No 35 Decommission Demobilization Of The Construction Equipment And Support Systems. Removal And Disposal Of All Waste Resulted From The Construction Activities. 01 No Tender Link : Https://Comms.Southsudanngoforum.Org/C/Tenders