Quotation are invited for Service and Maintenance of Four (4) ICC Generators for a Period of 12 Months Scope of Service 6.1 Annual Service (all data and test results have to be recorded) 6.1.1 Supply and Replace Supply and change all oil Supply and change fuel filters Supply and change oil filters Supply and replace jacket water heater Replace coolant and flush radiator 6.1.2 Test Radiator coolant strip test Sludge/water dip test on all diesel tanks 6.1.3 Inspect Air inlet Oil filter Oil leak Oil level Fuel filter Prim/Sec Fuel leak / Fuel water trap Fuel and fuel tank hose Radiator/heat exchanger Coolant Jacket water heater Fan belt tension/condition Fan drive pulley and fan Battery condition / Battery electrolyte level Water pump condition Turbo charge condition Crank case breather Canopy/plant room condition 6.1.4 Wash and Clean Wash and clean engines Wash and clean radiators Clean radiator core and clear blockages 6.1.5 Engine Run/Checks Simulate low oil pressure Simulate high engine temperature Simulate low water level Simulate over/under frequency Simulate over/under voltage Simulate low oil pressure Start attempts Check governor functions Check charging alternator Check coupling noises 6.1.6 Control Panel Checks Main failure test Check change-over timing Check on load run period Check delay unit shut down Check plant selector (Auto) Check fan/motor isolators Check correct programme on all controllers 6.1.7 Batteries Load balances test Load test all batteries Supply battery test reports on all batteries Check on load run period Check delay unit shut down Check plant selector (Auto) Check fan/motor isolators 6.2 Quarterly Inspection service (all data and test results have to be recorded) 6.2.1 Inspect: Air inlet Oil filter Oil leak Oil level Fuel filter Prim/Sec Fuel leak Fuel water trap Fuel hose Radiator/heat exchanger Coolant Jacket water heater Fan belt tension/condition Fan drive pulley and fan Battery condition Battery electrolyte level Water pump condition Turbo charge condition Crank case breather Canopy/plant room condition 6.2.2 Wash and clean: Wash and clean engines Wash and clean radiators 6.2.3 Engine run/checks: Simulate low oil pressure Simulate high engine temperature Simulate low water level Simulate over/under frequency Simulate over/under voltage Simulate low oil pressure Start attempts Check governor functions Check charging alternator Check coupling noises 6.2.4 Control panel checks: Main failure test Check change-over timing Check on load run period Check delay unit shut down Check plant selector (Auto) Check fan/motor isolators Tender Link : https://icc.co.za/careers-and-vendors/vendor-opportunities/
We takes all possible care for accurate & authentic tender information, however Users are requested to refer Original source of Tender Notice / Tender Document published by Tender Issuing Agency before taking any call regarding this tender.
